首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献，搜索用时 31 毫秒
1.
Tofu was prepared from 13 soybean varieties according to three different methods (bench, pilot, and production methods). Different soybean varieties showed significant differences in storage protein composition (glycinin and beta-conglycinin). The beta-conglycinin (7S) and glycinin (11S) contents were 7.3-9.9 and 14.1-22.9% on the dry matter basis, respectively. The 11S/7S protein ratio varied from 1.64 to 2.51 among the varieties. Glycinin content and 11S/7S protein ratio of the 13 varieties did not change significantly from soy milk to tofu for the production and pilot methods. Soybean 11S/7S protein ratio positively correlated with the 11S/7S ratio of soy milk and tofu (0.57 < or = r < or = 0.83, p < or = 0.01). The correlation coefficient depended on the processing method. Processing method affected 7S and 11S protein contents of tofu and their contribution to tofu hardness, yield, and sensory quality. This may explain in part the contradictory findings of the relationships between storage proteins and tofu quality because processing methods differed in various studies.  相似文献   

2.
The effect of isoflavone on soy milk and tofu astringency was investigated, and no consistency was found between an undesirable astringent taste and isoflavone contents. Isoflavone-enriched extract (approximately 39% isoflavones) showed no astringency. Soybean foods having high amounts of isoflavones showed less astringency. About 80% of isoflavones exist freely in both soy milk and tofu, but 55% of phytates (which play an important role in the formation of the tofu curd network) exist freely in the soy milk, and 6-13%, on the basis of coagulation, existed freely in the tofu curds. A 1% potassium phytate solution at pH 7 showed the very same astringency as soy milk; however, calcium phytate at the same concentration and pH showed no undesirable sensation. Thus, it is assumed that the astringent characteristics caused by phytic ions in soy milk are lost upon conversion of phytic ions to their insoluble salt forms during soy milk coagulation.  相似文献   

3.
Protein quality in six soybean varieties, based on subunit composition of their protein, was correlated with quality of the produced tofu. Also, protein changes due to a pilot plant processing method involving high temperature/pressure and commercial rennet as coagulant were assessed. In each soybean variety, glycinin (11S) and β-conglycinin (7S) as well as 11S/7S ratio significantly changed from beans to tofu. Between varieties, the 11S/7S protein ratio in seed indicated genotypic influence on tofu yield and gel hardness (r = 0.91 and r = 0.99, respectively; p < 0.05). Also, the 11S/7S ratio correlated with soymilk pH (r = 0.89, p < 0.05), leading to a relationship between soymilk pH with protein recovery and yield of tofu (r = 0.94 and r = 0.91, respectively; p < 0.05). The soybean β'-subunit of 7S protein negatively influenced tofu hardness (r = -0.91, p < 0.05). Seed protein composition and proportion of 7S protein subunits under the applied production method had an important role in defining tofu quality.  相似文献   

4.
Protein quality, based on its subunit composition, in okara obtained as a byproduct during hydrothermal cooking of soy milk was assessed. The composition of 7S and 11S protein fractions was correlated with the physicochemical properties of protein in okara produced from six soybean varieties. The basic 7S globulin (Bg7S) and 11S protein were two main proteins in okara. Investigated soybean genotypes produced okara with mainly acidic A(5) and basic B(1,2,4) polypeptides of 11S proteins. Soybean 11S content was not an indicator of okara protein recovery or extractability. Of all tested relationships, extractable soluble protein content of okara was influenced only by soybean Bg7S (r = 0.86; p < 0.05) and its light subunit contents (r = 0.93; p < 0.05). Okara protein recovery depended on Bg7S heavy subunit content in soybeans (r = 0.81; p < 0.05). The high quantity of vegetable protein in okara (around 35%) and very high protein extractability (around 85%) qualify this byproduct for potential application in food preparation as a functional ingredient.  相似文献   

5.
A rapid titration method was developed for predicting the optimal coagulant concentration for making filled tofu. Cooked soymilk (350 mL, 20 degrees C) in a 400 mL beaker was stirred by a magnetic stirrer to form a swirl. The quick-acting coagulant solution (20.0 Brix) was added into the soymilk at 1.0 mL/min. The swirl depth decreased when the soymilk viscosity increased as a result of increasing the concentration of coagulant in the soymilk. At a suitable stirrer speed, the swirl finally disappeared but the soymilk still maintained rotation, and then the swirl reappeared after around 1 min. The critical point of coagulant concentration (CPCC) was calculated on the basis of the volume of coagulant consumed to get the swirl to disappear. The influences of several factors on the CPCC were investigated, including coagulant addition rate, soymilk temperature, soymilk concentration, soymilk volume, stir bar length, and container size. For validation, 33 soybean samples were used to determine their CPCCs and make filled tofus. The results indicated that CPCC was a characteristic parameter of soymilk and could be used as an effective indicator for predicting optimal coagulant concentration.  相似文献   

6.
The contribution of soybean protein to the physical properties of tofu, a product manufactured by curdling soy milk with coagulants such as calcium or magnesium chloride, was studied by comparing the properties of soy milk prepared from soybeans with different subunits (I, IIa, and IIb) of glycinin with amino acid residues deleted. The breaking stress value of the tofu curds prepared from soybeans having group I was higher than those without group I. The soy milks having group I contained more protein particles and showed more sensitivity to calcium and magnesium ions than those without group I. The amounts of glycinin and protein particles were higher in the soy milks having group I than those in the soy milks without group I. To elucidate the influence of each group on the breaking stress, the glycinin content was adjusted to an identical level in soy milks having each group. Among the tofu curds from three groups, their order of hardness according to their breaking stress was IIa, IIb, and I. The order of particle content among these soy milks was also IIa, IIb, and I. Therefore, the results suggested that the breaking stress value of the tofu curd is dependent upon the number of protein particles in the soy milk and that the number of the particles is determined by the proportion and structure of glycinin in the soybean.  相似文献   

7.
Isoflavones are novel nutraceutical constituents of soybeans, but considerable amounts are lost in the whey during conventional tofu manufacturing. In this study, in a small-scale process, 2 mL of koji enzyme extract (soybean koji/deionized water, 1/3, w/v) was combined with 600 mL of soy milk, and 30 mL aliquots were incubated at 35 degrees C for 0, 30, 60, 120, and 300 min, for enzyme pretreatment. After each treatment time, soy milk was heated to 85 degrees C, CaSO4 was added to aggregate protein, and the mixture was centrifuged to separate the solids (tofu) from the whey. The tofu yield and moisture contents from soy milk treated for 30 or 60 min were higher than those from soy milk treated for 0 (control), 120, or 300 min. The protein content of freeze-dried tofu varied in a limited range, and native PAGE and SDS-PAGE patterns revealed slight quantitative and qualitative variations among products. Soy milk daidzein and genistein contents increased while daidzin and genistin contents decreased as the time of enzyme pretreatment of the soy milk increased. After 30 min of pretreatment, daidzin, genistin, daidzein, and genistein contents recovered in tofu products were higher than those of the control. In a pilot-scale process, aliquots (3 L) of soy milk were enzyme-treated for 30 min, aggregated with CaSO4, and hydraulically pressed to remove the whey. As in pretreatments, soy milk daidzein and genistein contents increased while daidzin and genistin contents decreased. In a comparison of the control and enzyme-treated tofu products, the total recoveries of daidzin, genistin, daidzein, and genistein in the tofu products increased from 54.9% to 64.2%. When the tofu products were subjected to a sensory panel test, both products were judged acceptable.  相似文献   

8.
The present study investigated the changes of the bioavailable isoflavones, including daidzin, genistin, daidzein, and genistein, during the making of tofu. The amount of extracted daidzin and genistin in soy milk increased with increasing water-to-bean ratios from 5 to 9 and reached the maximum level at the ratios of 9-11. On the other hand, the amount of extracted free isoflavones (daidzein and genistein) was not affected by the water-to-bean ratio at the range of 5-11, and their extracted amounts in soy milk were 2-4-fold those in raw soybean. It is suggested that these free isoflavones are mainly derived from daidzin, genistin, malonyldaidzin, and malonylgenistin through enzymatic hydrolysis during the making of soy milk. Tofu made with water-to-bean ratios of 9:1 and 10:1 had the maximal retentions of daidzin and genistin, which were due to the fine homogeneous network microstructure that is supposed to be more effectively retained through hydrophilic interaction with protein. On the contrary, the retained amount of free isoflavones decreased significantly as the water-to-bean ratio increased from 7 to 11, due to their weakening hydrophobic interaction with protein. In this study it was found that the homogeneous microstructure of tofu improved the retention of hydrophilic daidzin and genistin and that the increased amount of drained water does not significantly reduce their retention in the final tofu products as generally imagined.  相似文献   

9.
Lipid holding in tofu (soybean curd) has such stability that it is not released even when it is cooked. The lipid in soy milk is incorporated into the tofu with coagulation of proteins on processing by the addition of a calcium salt. In this study, the incorporation of lipid into the coagulum was examined from the association with protein. The lipid in soy milk was obtained as the floating fraction by centrifugation. The floating fraction decreased by the addition of calcium chloride prior to forming a protein coagulum. When half of the protein coagulated, all of the floating fraction became inseparable. The protein in soy milk, then, was separated into particulate and soluble fractions by centrifugation. The decrease of the floating fraction with added calcium chloride was parallel to the coagulation of the particulate protein. The association of the floating fraction and the soluble protein occurred after the new particles formed from the soluble proteins. These results indicated that the lipid incorporation took place by the conjugation of the lipid and protein particles.  相似文献   

10.
Harovinton, a variety of tofu type soybean, and 11 derived null soybean genotypes lacking specific glycinin (11S) and beta-conglycinin (7S) protein subunits were investigated to determine whether changes in protein composition affected the protein recovery in soymilk and its soluble fractions after various centrifugation steps. As both heating and homogenization have a marked effect on the increase in protein solubility, the changes occurring during these processing steps were studied for each soybean genotype. Harovinton and 11S-null genotypes showed significantly higher protein yields than the other genotypes evaluated. Subunits of group I (A(1), A(2)) of glycinin had a negative impact on protein solubility in all treatments, but this effect was the greatest in unheated soymilk samples. Samples containing a high beta-conglycinin to glycinin ratio showed an effect of heating on the solubility of the protein, as beta-conglycinin subunits aggregate with heating. The presence of the alpha' subunit of beta-conglycinin aids in the recovery of protein in the supernatant prepared from lines containing group I (A(1,4) A(2)) glycinin. The results of this study will help determine which specific protein composition will confer an increased stability in soymilk and soymilk-derived products.  相似文献   

11.
The phytic acid (myo-inositol hexakisphosphate or InsP6) content of seed crops is important to their nutritional quality. Since it represents 75?±?10% of the total seed phosphorus (P), phytic acid is also important regarding the management of P in agricultural production. A low-phytate F5 line, No. T-2-250-4-20, was selected from the progeny of a cross between the low-phytate soybean line CX1834 and the Japanese commercial cultivar Tanbakuro. This line and its parents were grown in a field nursery, and the growth characteristics, phytate accumulation, and processing suitability for tofu were evaluated. At full maturity, the weight of seeds per plant of line T-2-250-4-20 was 5.2- and 1.3-fold higher than that of CX1834 and Tanbakuro, respectively. The amount of phytate-phosphorus as a percentage of the total P content in seeds was 23% in line T-2-250-4-20-34, 30% in CX1834, and 69% in Tanbakuro. No significant difference was observed among the three cultivars/lines in their seed magnesium (Mg), potassium (K), crude protein, and sugar. However, the calcium (Ca), crude fat and ash contents in seeds of line T-2-250-4-20-34 and Tanbakuro was lowered compared to that of CX1834. The breaking stress of tofu was estimated employing a rheometer with a decreasing concentration of the coagulant magnesium chloride (MgCl2), starting at 15.7?mmol?L?1. In tofu made from Tanbakuro, the concentration of MgCl2 required to achieve the maximum breaking stress was 12.6?mmol?L?1; however, it was 9.5?mmol?L?1 for tofu made from T-2-250-4-20-34 and CX1834. The tofu made from Tanbakuro was soft and broke at 6.3?mmol?L?1 MgCl2, but, in line T-2-250-4-20-34, harder tofu was made with lower MgCl2 concentrations. No difference was observed among the cultivars/lines in the SDS-PAGE patterns of protein in soymilk. These results indicate that we have developed a low-phytate soybean with adequate productivity, and confirmed that tofu made from the low-phytate T-2-250-4-20-34 soybean becomes coagulated and harder at a lower MgCl2 concentration than that from high-phytate soybean cultivars.  相似文献   

12.
The self-diffusion coefficient of water in soybean protein dispersion and tofu was measured by pulsed field gradient (PFG) NMR. A soy protein isolate (SPI) dispersion (6 and 12%, w/w) in water, calcium cross-linked precipitate, and tofu were used for comparison. The self-diffusion coefficient of water (D) in the SPI dispersion, 2.23 x 10(-9) m2/s, was estimated lower than that of free water, 2.6 x 10(-9) m2/s at 25 degrees C, and decreased as the SPI concentration increased. It further decreased by the addition of calcium chloride, reflecting the obstruction effect induced by the precipitates in addition to the hydration and hydrodynamic interaction in the protein dispersion. The two water regions in tofu were interpreted by the two-site K?rger model: D1 and D2 of soft tofu were 2.26 (+/-0.11) x 10(-9) and 6.84 (+/-0.34) x 10(-11) m2/s, respectively. The relative amount of proton (water) was p1 = 0.98 and p2 = 0.02 at 100 ms of diffusion time. The self-diffusion coefficients of water decreased in pressed tofu, and their relative amounts of water changed to p1 = 0.93 and p2 = 0.07. It was suggested that D1 corresponded to obstructed water in the network structure and D2 corresponded to hydrated water on the surface layer of pores formed in the protein network of tofu. The pore sizes estimated from the diffusion length of obstructed water were 21.3 microm in soft tofu and 20.8 microm in pressed tofu. The removal of fat from pressed tofu led to a decrease in D2 from 6.26 (+/-0.31) x 10(-11) to 3.53 (+/-0.18) x 10(-11) m2/s, and the relative amount of hydrated water increased from 0.07 to 0.14, which indicated hydrophobic hydration.  相似文献   

13.
High-performance liquid chromatographic methods were developed for the isolation and quantitative determination of the group B soyasaponins, including 2,3-dihydro-2,5-dihydroxy-6-methyl-4H-pyran-4-one (DDMP)-conjugated soyasaponins alphag, betag, and betaa, and their non-DDMP counterparts, soyasaponins V, I, and II, respectively, with formononetin used as the internal standard. The limits of quantification for soy products were 0.11-4.86 micromol/g. The within-day and between-days assay coefficients of variation were <9.8 and < 14.3%, respectively. The group B soyasaponin concentrations in 46 soybean varieties ranged from 2.50 to 5.85 micromol/g. Soy ingredients (soybean flour, toasted soy hypocotyls, soy protein isolates, textured vegetable protein, soy protein concentrates, and Novasoy) and soy foods (commercial soy milk, tofu, and tempeh) contained the group B soyasaponins from 0.20 to 114.02 micromol/g. There was no apparent correlation between isoflavone and soyasaponin concentrations in the soy products examined.  相似文献   

14.
The consumption of foods made from soybeans is increasing because of their desirable nutritional value. However, some soy foods contain high concentrations of oxalate and/or phytate. Oxalate is a component of calcium oxalate kidney stones, whereas phytate is an inhibitor of calcium kidney stone formation. Thirty tested commercial soy foods exhibited ranges of 0.02-2.06 mg oxalate/g and 0.80-18.79 mg phytate/g. Commercial soy foods contained 2-58 mg of total oxalate per serving and 76-528 mg phytate per serving. Eighteen of 19 tofu brands and two soymilk brands contained less than 10 mg oxalate per serving, defined as a low oxalate food. Soy flour, textured vegetable soy protein, vegetable soybeans, soy nuts, tempeh, and soynut butter exhibited greater than 10 mg per serving. The correlation between oxalate and phytate in the soy foods was significant (r = 0.71, P < 0.001) indicating that oxalate-rich soy foods also contain higher concentrations of phytate. There also was a significant correlation, based on molar basis, between the divalent ion binding potential of oxalate plus phytate and calcium plus magnesium (r = 0.90, P < 0.001) in soy foods. Soy foods containing small concentrations of oxalate and moderate concentrations of phytate may be advantageous for kidney stone patients or persons with a high risk of kidney stones.  相似文献   

15.
A total of 60 food samples commonly consumed in China were analyzed for phytate using the anion-exchange method and for calcium, iron, and zinc using atomic absorption spectrophotometry. The foods analyzed included those based on cereal grains and soybean. Phytate contents expressed on a wet weight basis ranged from 0 for foods made from starches to 1878 mg/100 g for dried stick-shaped soybean milk film. The calcium contents were between 2.08 mg/100 g for ground corn and 760.67 mg/100 g for diced fried soybean curd. The lowest values of iron and zinc were 0.04 mg/100 g for Panjin pearl rice cooked with discarding extra water and 0.08 mg/100 g for potato and bean starches, while the highest values of iron and zinc were observed in dried stick-shaped soybean milk film. Although many foods were relatively rich in calcium, zinc, and iron, many also contained a higher level of phytate. Of the 60 food samples, 34 foods had a phytate/calcium molar ratio >0.24, 53 foods had a phytate/iron molar ratio >1, 31 foods had a phytate/zinc molar ratio >15, and only 7 foods had a phytate x calcium/zinc >200. Phytate in foods impair the bioavailability of calcium, iron, and zinc, which to some extent depends upon food processing and cooking methods.  相似文献   

16.
The aggregation behavior during heating of a solution containing soy protein and whey protein isolate (WPI) was studied using rheology, confocal microscopy, gel filtration, and electrophoresis. Soy/WPI mixtures formed gels at 6% total protein concentration with a high elastic modulus (G') and no apparent phase separation. The ratio of soy to WPI was fundamental in determining the type of network formed. Systems containing a high soy to WPI ratio (>70% soy protein) showed a different evolution of the elastic modulus during heat treatment, with two apparent stages of network development. Whey proteins formed disulfide bridges with soy proteins during heating, and at low ratios of soy/WPI, the aggregates seemed to be predominantly formed by 7S, the basic subunits of 11S and beta-lactoglobulin. Size exclusion chromatography indicated the presence of high molecular weight soluble complexes in mixtures containing high soy/WPI ratios. Results presented are the first evidence of interactions between soy proteins and whey proteins and show the potential for the creation of a new group of functional ingredients.  相似文献   

17.
  相似文献   

18.
豆浆富含植物蛋白,但由于植物蛋白相较动物蛋白不易被人体吸收。利用产蛋白酶菌株发酵豆浆,可将植物蛋白降解成多肽和氨基酸,提高其消化吸收率。传统农家酱是以大豆为主要原料的传统发酵食品,含有大量能够水解大豆蛋白的优良菌株。该研究从传统农家酱中分离到8株产蛋白酶的芽孢杆菌并用于豆浆处理,处理后豆浆的可溶性肽含量显著提高,其中菌株BJ-20处理效果最显著;氨基态氮含量和水解度也有显著变化,其中BJ-6处理后的豆浆最佳,氨基态氮含量提高了10.87%,水解度为23.49%。同时,处理后豆浆的组织状态得到了明显改善。本研究丰富了豆类发酵菌种库,提高了大豆蛋白利用率,丰富了大豆产品种类,为大豆保健产品开发提供参考及理论支持。  相似文献   

19.
Commercial soy-based foodstuffs, including beverages ( n = 15), cow's milk supplemented with soy isoflavones ( n = 1), snacks ( n = 1), and biscuits ( n = 2), were analyzed to find any link between alterations in protein quality, safety (antigenicity), functionality (antioxidant activity), and food processing. Protein content was analyzed by the Kjeldhal method and available lysine by OPA assay. Chromatographic (RP-HPLC) and electrophoretic (SDS-PAGE) protein profiles were obtained to monitor modifications in the structure of soy allergens. The antigenicity was estimated by immunoblotting against soy total antibodies. Total phenol content was measured by Folin-Ciocalteu, while peroxyl radical scavenging activity of the sample was determined by ORAC FL assay. Protein content did not differ of those declared by the producers. Lysine availability was higher in liquid soy beverages compared to that in other soy foodstuffs studied here. 7S and 11S soy allergens were detected by RP-HPLC and SDS-PAGE, respectively. Both data indicated changes in soy protein patterns due to processing of instant powdered soymilk, soy snacks, and biscuits. Immunoblotting assay showed modifications in the antigenic response of these foodstuffs based on soy, suggesting that their processing had altered the structure of soy allergens. RP-HPLC, SDS-PAGE, and immunoblotting resulted in adequate analytical approaches for detecting changes in protein structure due to processing and adulteration. Protein quality, antigenicity, and antioxidant activity of soy products can be affected as a function of the intensity of the thermal processing.  相似文献   

20.
An investigation by aroma extract dilution analysis (AEDA) of the aroma concentrate of soy milk made from a major Japanese soybean cultivar, Fukuyutaka (FK), revealed 20 key aroma compounds having flavor dilution (FD) factors of not less than 64. Among them, 2-isopropyl-3-methoxypyrazine, cis-4,5-epoxy-(E)-2-decenal, trans-4,5-epoxy-(E)-2-decenal, 3-hydroxy-4,5-dimethyl-2(5H)-furanone, and 2'-aminoacetophenone were identified as the key aroma compounds in soy milk for the first time. (E,E)-2,4-Decadienal exhibiting a fatty note and trans-4,5-epoxy-(E)-2-decenal exhibiting a metallic/sweet note were detected as having the highest FD factors of 4096, followed by hexanal (green), (E)-2-nonenal (fatty), and (E,E)-2,4-nonadienal (fatty) having FD factors of 1024. Although all of these compounds might be generated from lipids, various aroma components, which were thought to be generated from amino acids, sugars, and ferulic acid, were detected having FD factors of 64-256. Investigation by comparative AEDA experiments of the soy milk aroma concentrates of two cultivars for soybean curd and soy milk, FK and Vinton81 (VT), and one cultivar for boiled beans, Miyagishirome (MY), revealed that most of the key aroma compounds were common to all of them, but 2-isopropyl-3-methoxypyrazine, exhibiting a pea-like/earthy note, was detected only in FK and VT. In addition, a sensory experiment revealed that the pea-like/earthy notes in FK and VT were significantly stronger than that in MY. These results demonstrated that a pea-like/earthy note contributed by 2-isopropyl-3-methoxypyrazine might be one of the essential characteristics to describe soy milk aromas.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号