共查询到20条相似文献，搜索用时 62 毫秒
1.
棉籽粕双螺杆挤压脱毒中几个工艺参数的研究 总被引：1，自引：1，他引：0
利用自行开发的双螺杆食品挤压机对棉籽粕进行挤压脱棉酚试验,考察了含水率、螺杆转速和喂料速度等参数对脱毒效果与挤出产量的影响。实验中采用响应表面法进行实验方案设计和数据分析。结果表明：减低含水率、喂料速度,提高螺杆转速可使脱毒效果改善。喂料速度是影响挤出产量的主要因素。喂料速度越大,产量越大,因而实际中脱毒效果与产量间存在如何均衡的问题。文中相应给出了本实验条件下的几个响应模型,用以评价各加工变量的影响。实验结果还表明本研究所用的双螺杆挤压机的结构参数在棉籽粕挤压脱毒方面是卓有成效的。 相似文献
2.
高水分大豆蛋白组织化生产工艺和机理分析 总被引：15，自引：4，他引：15
以低温豆粕为原料，应用带冷却工艺的双螺杆挤压实验室工作站，开发出高水分组织化大豆蛋白产品的生产工艺；分析了螺杆转速、物料湿度、喂料速度和机筒温度等操作参数对产品质构和色泽的影响规律；利用扫描电镜对高水分组织化大豆蛋白产品的微观结构进行了观察和分析。结果表明：机筒温度在150℃左右时，产品具有较好的组织化度、色泽及口感；随着物料水分的增加，产品的组织化度、粘着性和明度指数逐渐增加，而硬度和咀嚼度逐渐降低；随着螺杆转速的增加，产品的组织化度、硬度、粘着性和咀嚼度均有增加的趋势；喂料速度对产品的表观形态影响较大，喂料速度较大时，产品表观粗糙、组织化度降低。单因素实验优选的操作参数为：机筒温度145℃～155℃，物料湿度45％～50％，螺杆转速90～160 r/min，喂料速度20～40 g/min。结合对生产工艺和产品微观结构分析，提出了高水分组织化大豆蛋白产品形成过程的“膜状气腔”理论假设，以供讨论和指导生产实践。 相似文献
3.
亚麻籽粉含水率对其蛋白质变性温度的影响 总被引：1，自引：0，他引：1
本文研究亚麻籽粉含水率对其蛋白质变性温度的影响,通过对亚麻籽热变性的研究,为下一步亚麻籽的脱毒试验研究奠定一定的理论基础.应用差示扫描量热(DSC)技术测定不同的亚麻籽含水率下的亚麻籽粉蛋白质变性温度,分析在不同的条件下亚麻籽粉蛋白质变性温度特性.试验表明,亚麻籽粉蛋白质的变性温度较高,在129～143℃之间;随着升温速率的提高,DSC曲线的峰幅增大,峰形尖锐,变性温度升高,吸热焓值变化不大;亚麻籽蛋白质的变性温度与含水率有密切的关系,随含水率升高而降低.研究为亚麻耔深加工和利用提供了一定的理论依据. 相似文献
4.
香菇双螺杆挤压膨化机的设计与试验 总被引：1，自引：0，他引：1
针对现有双螺杆挤压膨化设备生产香菇膨化产品时存在物料堵塞、预熟度低、作业参数缺失等问题而导致生产的产品膨化率低、吸水性差、硬度高等缺陷,该研究设计了一种香菇双螺杆挤压膨化设备,并对设备中的关键部件喂料搅拌防堵装置、预熟调质装置与双螺杆结构参数进行了设计与确定。同时,为探究设备中的作业参数对产品膨化性能的影响,研究了设备的螺杆转速、膨化温度、物料含水率对产品的膨化率、硬度、脆度、吸水性的影响。结果表明:影响膨化率的显著性顺序依次为螺杆转速、物料含水率、膨化温度;影响硬度的显著性顺序依次为螺杆转速、膨化温度、物料含水率;影响脆度的显著性顺序依次为膨化温度、物料含水率、螺杆转速;影响吸水性的显著性顺序依次为膨化温度、物料含水率、螺杆转速。其次,结合各因素交互作用的影响规律与目标优化结果,得出设备的最佳作业参数为:螺杆转速167.23r/min,膨化温度151.68℃,物料含水率16.83%,此时,产品的膨化率、硬度、脆度、吸水性分别为4.04%、18.61N、-8.46mm/cm^2、313.86%。将优化后的参数值在设备中进行了生产性应用,得到生产值与优化值的误差均小于4%,最大生产率为165 kg/h。与扬州大学机械工程学院实验室内的现有设备相比,在提高物料送料的连续性与调质熟化度的基础上,膨化率提高了25.00%,硬度降低了48.21%、脆度提升了40.55%、吸水性提高了62.35%。因此,该机的设计可为香菇膨化产品的开发提供了一种较为成熟的技术装备。 相似文献
5.
热压凝胶法制备营养质构米及其营养性质研究 总被引：1，自引：1，他引：0
为弥补食用精白米导致营养不良的状况,以大米加工过程中产生的碎米作为原料和载体,产生的米糠作为天然营养强化剂,采取热压凝胶法制备营养质构米。在预试验的基础上,采用响应面法考察热压凝胶过程条件包括喂料含水率,螺杆转速,5个加热区机筒温度对营养质构米的质构和营养特性的影响,得出制备最佳工艺条件:当喂料转速为30r/min,米糠添加量为4%,物料含水率为30%,螺杆转速为17.7r/min,5个区机筒温度分别为50,65,85,100,95～97℃。在此条件下制备的营养质构米含有质量分数总膳食纤维11.44%,蛋白质11.62%,脂肪6.49%,而维生素为B12.07μg/g,维生素B20.31μg/g和γ-谷维素12.04mg/100g。相比于天然精白米,质构特性相近,但维生素B1,维生素B2,γ-谷维素分别增加了1.17,0.06,5.83μg/g,为营养质构米工业化生产提供参考。 相似文献
6.
水产沉性颗粒饲料挤压蒸煮工艺对其理化特性的影响 总被引：3，自引：2，他引：1
为了规模化生产出低污染、高转化率的环保型水产沉性颗粒饲料,选用双螺杆挤压机对水产全价配合原料进行挤压熟化研究。以沉性水产硬颗粒饲料理化特性(膨化度、近似密度、糊化度、耐久性和水中稳定性)为重要指标,采用表面响应分析法研究了物料含水率（22%～38%）、套筒温度（70～170℃）和螺杆转速（73～107?r/min）对其挤压工艺和饲料理化特性的影响规律,SEM分析其微观结构。结果表明：物料含水率、套筒温度和螺杆转速均显著影响饲料的理化特性。中高物料含水率和套筒温度及低螺杆转速时,才能获得理想的沉性高熟化水产颗粒饲料,其理化特性具有低膨化度（1.14）,高近似密度（757.6?g/L）、糊化度（879.5?g/kg）、耐久性（96.6%）和水中稳定性（88.7%）。SEM分析显示优化条件（物料含水率31%,套筒温度126℃,螺杆转速78?r/min）下生产的颗粒饲料结构光滑质密。该研究可为发展高效、低耗、低碳高品质沉性水产饲料研究和生产提供参考。 相似文献
7.
该文通过4因素5水平二次正交旋转组合试验，研究了用于浸油的玉米胚挤压膨化预处理过程中的挤压系统参数(套筒温度、模孔孔径、物料含水率、螺杆转速)对考察指标(残油率、剪切强度、密度)的影响规律。得到最佳挤压工艺参数：模孔直径9 mm，物料出口温度93℃，喂入物料含水率13.3%，螺杆转速238 r/min，在此条件下得出残油率最优值为0.40%。和传统工艺相比，浸提时间缩短一半，膨化物的密度与轧坯和预轧样相比分别增加29.3%和13.8%。只要参数选择合适，可使原设备的浸出能力提高60%～120%。 相似文献
8.
不同工艺参数下苜蓿草粉环模制粒机流场的模拟与验证 总被引：1，自引：1，他引：0
环模制粒成型技术以其高效率、高成型率、强适应性等优点广泛应用于生物质能源和饲料产业等领域。该文以苜蓿草粉为原料,应用POLYFLOW软件对环模制粒机挤压区流场进行数值模拟,研究了喂料量、环模转速和物料含水率的变化对流场压力、速度、剪切速率和黏度分布特性的影响规律,并以试验验证,旨在为生产工艺的有效控制提供参考依据。结果表明:在结构参数等条件一定的情况下,增大喂料量,流场压力升高,挤压成型区域扩大,且物料以较快的速度作层流运动,流场剪切速率降低,黏度增大,出模压力和成型密度较大;减小环模转速,流场压力和挤压成型区增大,流动速度减小,剪切速率降低,黏度较大,但出模压力和成型密度降低;物料含水率降低使流场压力、黏度、出模压力和成型密度增加。通过比较得出:当喂料量为6 t/h、环模线速度为6.5 m/s和物料含水率为15%时所形成的流场有利于苜蓿草粉的制粒成型。 相似文献
9.
10.
11.
【目的】以富士（Fuji）、 秦冠（Qinguan）嫁接在平邑甜茶（Malus hupehensis Rehd.）上的当年生盆栽苗为试验材料,采用砂培方法,研究了缺氮胁迫和干旱对富士和秦冠生长情况、 光合参数、 植株各部位氮磷钾含量及氮素利用效率的影响,分析比较了低氮干旱条件下富士和秦冠生长及氮素利用的差异,以期为果树生产高效肥水利用提供理论指导。【方法】试验共设四个处理: 正常氮正常水（ZZ）、 低氮正常水（DZ）、 正常氮干旱（ZG）、 低氮干旱（DG）。氮素和水分均设置两个水平,分别为正常氮（6 mmol/L NO-3-N）、 低氮（0.3 mmol/LNO-3-N）、 正常供水（保持盆中砂子相对含水量为饱和含水量的80%~85%）、 干旱处理（保持盆中砂子相对含水量为饱和含水量的60%~65%）。【结果】富士和秦冠的生物量（茎和叶）、 株高茎粗等生长指标以及光合速率、 气孔导度、 蒸腾速率均为正常氮正常水（ZZ）＞低氮正常水（DZ）＞正常氮干旱（ZG）＞低氮干旱（DG）,并且相对应处理下秦冠的以上指标均高于富士;正常供水下,缺氮处理使富士、 秦冠的根冠比比正常氮处理均有所增加,富士提高了2.05%,秦冠提高了22.40%。富士和秦冠的氮、 磷、 钾含量均表现出正常氮正常水（ZZ）＞低氮正常水（DZ）＞正常氮干旱（ZG）＞低氮干旱（DG）; 氮、 钾元素含量在植株各部位的分布顺序依次是叶＞根＞茎,磷元素则是根＞叶＞茎;光合氮素利用效率（PNUE）和氮素利用效率表现为秦冠处理之间差异极显著,富士处理之间差异不显著;秦冠的PNUE和NUE明显高于富士,在低氮正常水（DZ）处理下,秦冠氮肥利用率比富士高42.07%,在低氮干旱（DG）处理下高64.14%;低氮胁迫下富士和秦冠的NUE显著提高,并且秦冠提高的幅度高于富士。【结论】施用氮肥能够显著提高富士与秦冠的干物质量,同等水肥条件下,秦冠生长优于富士;水分亏缺会减少叶片对氮的吸收,干旱条件下适度增施氮肥,可提高果树的抗旱能力;低氮干旱胁迫下秦冠的生长指标、 光合指标及氮素利用效率指标均优于富士,表现出较强的抗低氮干旱胁迫的能力。 相似文献
12.
Kyle Devey Michael Mucalo Gordon Rajendram Joseph Lane 《Communications in Soil Science and Plant Analysis》2015,46(4):72-80
Laser-induced breakdown spectroscopy (LIBS) is a new technique for the analysis of plant material. This study investigates the application of LIBS to pasture-based plant samples. The LIBS measurements were obtained from pelletized pasture samples (100 samples) that had been also analyzed by inductively coupled plasma–optical emission spectroscopy (ICP-OES) following microwave digestion for calibration and comparison purposes. Comparisons for elements sodium (Na), potassium (K), magnesium (Mg), calcium (Ca), manganese (Mn), iron (Fe), copper (Cu), zinc (Zn), boron (B), phosphorus (P), and sulfur (S) showed that LIBS could be used for almost all the standard profile total elements with concentrations down to low mg/kg levels (observed error of Na: 0.024 percent, K: 0.18 percent, Mg: 0.016 percent, Ca: 0.073 percent, P: 0.017 percent, Mn: 31 mg/kg, Fe: 150 mg/kg, Zn: 6.6 mg/kg, and B: 1.1 mg/kg). Elemental analysis at less than mg/kg levels was not possible using LIBS. The elements S and Cu were particularly difficult to analyze with reliability using LIBS at the concentration levels found in the plant samples. Replacing microwave digestion and subsequent ICP analysis with a direct analysis of dried plant samples using LIBS has the potential to improve the productivity and reduce the cost of testing. 相似文献
13.
《中国生态农业学报》2014,(8)
正The Center for Agricultural Resources Research(CARR),the Institute of Genetics and Developmental Biology(IGDB),Chinese Academy of Sciences,invites applicants for several research group leader positions.CARR is one of the research organizations in Chinese Academy of Sciences(CAS).We seek nominations and applications from individuals who have expertise and a record of accomplishment in research areas related to ecology,agro-hydrology, 相似文献
14.
M.A. Callaham Jr. J.M. BlairT.C. Todd D.J. KitchenM.R. Whiles 《Soil biology & biochemistry》2003,35(8):1079-1093
The responses of tallgrass prairie plant communities and ecosystem processes to fire and grazing are well characterized. However, responses of invertebrate consumer groups, and particularly soil-dwelling organisms, to these disturbances are not well known. At Konza Prairie Biological Station, we sampled soil macroinvertebrates in 1994 and 1999 as part of a long-term experiment designed to examine the effects and interactions of annual fire, mowing, and fertilization (N and P) on prairie soil communities and processes. For nearly all taxa, in both years, responses were characterized by significant treatment interactions, but some general patterns were evident. Introduced European earthworms (Aporrectodea spp. and Octolasion spp.) were most abundant in plots where fire was excluded, and the proportion of the total earthworm community consisting of introduced earthworms was greater in unburned, unmowed, and fertilized plots. Nymphs of two Cicada genera were collected (Cicadetta spp. and Tibicen spp.). Cicadetta nymphs were more abundant in burned plots, but mowing reduced their abundance. Tibicen nymphs were collected almost exclusively from unburned plots. Treatment effects on herbivorous beetle larvae (Scarabaeidae, Elateridae, and Curculionidae) were variable, but nutrient additions (N or P) usually resulted in greater densities, whereas mowing usually resulted in lower densities. Our results suggest that departures from historical disturbance regimes (i.e. frequent fire and grazing) may render soils more susceptible to increased numbers of European earthworms, and that interactions between fire, aboveground biomass removal, and vegetation responses affect the structure and composition of invertebrate communities in tallgrass prairie soils. 相似文献
15.
Grete Skrede Berit Karoline Martinsen Anne-Berit Wold Stein-Erik Birkeland Kjersti Aaby 《Acta Agriculturae Scandinavica, Section B - Plant Soil Science》2013,63(3):193-208
Abstract A 3-year study was carried out to investigate quality parameters in 14 tree fruit and berry species grown in southern Norway. The species were blueberry, apple, aronia, sour cherry, sweet cherry, red raspberry, strawberry, blackcurrant, gooseberry, red currant and elderberry, harvested along with wild bilberry, cloudberry and lingonberry. Significant differences between species were identified for all quality parameters. The coefficient of variation between species was lowest for pH (12.5%), dry matter (18.9%) and soluble solids (25.3%), followed by titratable acids (59.3%), total phenolics (83.8%), antioxidant capacity FRAP (85.7%) and antiradical power by the DPPH-assay (97.8%), total monomeric anthocyanins (132%) and ascorbic acid (137%). Average coefficient of variation within species were lower and ranged from 4 (pH) to 62% (ascorbic acid). Only the FRAP values were significantly affected by harvesting year with lower levels in 2004 than in 2005 and 2006. There were significant interactions between species and harvesting year for dry matter, soluble solids, pH, ascorbic acid and FRAP. The results indicate generic ranges in composition within species independent upon growing location and climate, and the composition of the tree fruits and berries is not likely to deviate from these ranges. It is concluded that desirable composition of tree fruits and berries and their products should primarily be achieved by selection among species rather than searching fors broadened variation within individual species. 相似文献
16.
《Communications in Soil Science and Plant Analysis》2012,43(7):865-877
Potassium (K) fixation and release in soil are important factors in the long-term sustainability of a cropping system. Changes in K concentration and characteristics of K fixation and release in rhizosphere and nonrhizosphere soils in the rapeseed (Brassica napus L.)–rice (Oryza sativa L.) rotation were investigated using a rhizobox system. The concentrations of different forms of K in both rhizosphere and nonrhizosphere soils decreased with plants compared to without plants, regardless of K fertilizer application. Potassium uptake by crops mainly came from the rhizosphere soil. In the treatment without K fertilizer (–K), the main form of K supplied by the soil to the crops was 1.0 mol L?1 nitric acid (HNO3) nonextractable K, followed by nonexchangeable K, and then exchangeable K. In the treatment with K fertilizer (+K), the main K forms supplied by the soil to the crops were exchangeable K and nonexchangeable K. The amount and rate of K fixation after one cycle of the rapeseed–rice rotation was greater in rhizosphere soil than in nonrhizosphere soil. The amount and rate of K fixation of soil in the +K treatment were significantly less than in the –K treatment. The cumulative amounts of K released with 1.0 mol L?1 ammonium acetate (NH4OAc) and 1.0 mol L?1 HNO3 extraction increased with the increasing numbers of extractions, but the K-releasing power of soil by successive extraction decreased gradually and finally became almost constant. The release of K was less in rhizosphere soil than in nonrhizosphere soil. The release of K in the +K treatment was similar to that in the –K treatment in rhizosphere soil, but the K release in nonrhizosphere soil was greater with the +K than the –K treatment. Overall, the information obtained in this study will be helpful in formulating more precise K fertilizer recommendations for certain soils. 相似文献
17.
Y. Bashan J. J. Bustillos L. A. Leyva J.-P. Hernandez M. Bacilio 《Biology and Fertility of Soils》2006,42(4):279-285
Inoculation of wheat seedlings with the plant growth-promoting bacterium Azospirillum brasilense Cd was immobilized in alginate microbeads and, without applying any stress, significantly increased the quantity of several
photosynthetic pigments, such as chlorophyll a, chlorophyll b, and the auxiliary photoprotective pigments violaxanthin, zeaxanthin, antheroxanthin, lutein, neoxanthin, and β-carotene.
This resulted in greener plants with no apparent visible stress. After monitoring the quantity of photosynthetic pigments
for 4 weeks, we observed that inoculated plants had higher quantities of pigments in shoot and stem. The greatest difference
in the quantity of all pigments between inoculated and noninoculated plants occurred in the first week of growth. Regardless
of treatment, the quantity of pigments in stems was three to four times less than the quantity of these pigments in shoots.
Application of Azospirillum, either as liquid inoculant or as alginate microbeads, did not alter the positive effect of the bacteria on pigment production
or the positive response of the plants towards A. brasilense Cd inoculation. 相似文献
18.
Dhritiman Ghosh Velusamy Srinivasan Olli H. Tuovinen Aaron Peacock Mark Radosevich 《Soil biology & biochemistry》2009,41(6):1331-1334
We examined the community composition of microbes that colonized atrazine-containing beads buried in agricultural soils that differed in atrazine treatment history. Bacterial abundance was 5-40-fold greater in atrazine-fortified beads. In beads containing 20 mg atrazine kg−1 buried in soil with a history of atrazine application (conditioned soil), the abundance of Actinobacteria increased approximately 80-fold whereas in control soil, Actinobacteria were enriched only 10-fold and the gamma-Proteobacteria and Planctomycetes increased by 60- and 25-fold, respectively. The gamma-Proteobacteria were enriched by 120- and 230-fold in beads containing 200 mg atrazine kg−1 in conditioned and control soil, respectively. The results demonstrate that BioSep® beads are a suitable matrix for recruiting a diverse subset of the bacterial community involved in atrazine degradation. 相似文献
19.
Pilar García Juan-Vicente Monte Carlos Casanova Consuelo Soler 《Genetic Resources and Crop Evolution》2002,49(1):103-109
Arbitrary oligonucleotides were used as primers to amplifygenomic DNA of 48 wild Spanish populations of Agropyroncristatum, Elymus hispanicus,E. caninus,E. repens,Thinopyrum curvifolium, Th.junceum and Th.intermedium. Genetic diversity was analysedusing nineteen primers. The number of amplified products ranged from8 to 18 per primer and a total of 240 markers were scored. Differentlevels of intraspecific genetic diversity were found, the allogamousspecies E. repens andTh. intermedium being themost variable. Jaccard's similarity coefficients for internalmeasure within and between populations were used to produce a clusterdiagram. The results demonstrate differences in the degree ofsimilarity between taxonomic units. Interpopulational variability andinterspecific genomic relationships of these species arediscussed. 相似文献
20.
The effects of three commonly used fungicides on the colonization and sporulation by a mixture of three arbuscular mycorrhizal (AM) fungi consisting of Glomus etunicatum (Becker & Gerd.), Glomus mosseae (Nicol. & Gerd.) Gerd. & Trappe, and Gigaspora rosea (Nicol. & Schenck) in symbiosis with pea plants and the resulting response of the host-plant were examined. Benomyl, PCNB, and captan were applied as soil drenches at a rate of 20 mg active ingredient kg-1 soil 2 weeks after transplanting pea seedlings in a silty clay-loam soil containing the mixed inocula of AM fungi (AM plants). Effects of fungicides were compared to untreated plants that were inoculated with fungi (AM control). The effect of mycorrhizal inoculation on plant growth was also examined by including nonmycorrhizal, non-fungicide-treated plants (non-AM control). Fungicides or inoculation with AM fungi had only a small effect on the final shoot weights of pea plants, but had greater effects on root length and seed yield. AM control plants had higher seed yields and lower root lengths than the corresponding non-AM plants, and the fungicide-treated AM plants had intermediate yields and root lengths. Seed N and P contents were likewise highest in AM control plants, lowest in non-AM plants, and intermediate in fungicide-treated AM plants. All three fungicides depressed the proportion (%) of root length colonized by AM fungi, but these differences did not translate to reductions in the total root length that was colonized, since roots were longer in the fungicide-treated AM plants. Pea plants apparently compensated for the reduction in AM-fungal metabolism due to fungicides by increasing root growth. Fungicides affected the population of the three fungi as determined by sporulation at the final harvest. Captan significantly reduced the number, relative abundance, and relative volume of G. rosea spores in the final population relative to the controls. The relative volume of G. etunicatum spores was greater in all the fungicide-treated soils, while G. mosseae relative volumes were only greater in the captan-treated soil. These findings show that fungicides can alter the species composition of an AM-fungal community. The results also show that AM fungi can increase seed yield without enhancing the vegetative shoot growth of host plants. 相似文献