首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献，搜索用时 31 毫秒
1.
This paper investigated the feasibility of manipulating packaging polymers with various degrees of hydrophobicity to release two antioxidants, tocopherol and quercetin, at rates suitable for long-term inhibition of lipid oxidation in food. For example, one antioxidant can be released at a fast rate to provide short-term/intermediate protection, whereas the other antioxidant can be released at a slower rate to provide intermediate/long-term protection of lipid oxidation. Controlled-release packaging films containing tocopherol and quercetin were produced using ethylene vinyl alcohol (EVOH), ethylene vinyl acetate (EVA), low-density polyethylene (LDPE), and polypropylene (PP) polymers; the release of these antioxidants to 95% ethanol (a fatty food simulant) was measured using UV-vis spectrophotometry, and Fickian diffusion models with appropriate initial and boundary conditions were used to fit the data. For films containing only quercetin, the results show that the release of quercetin was much faster but lasted for a much shorter time for hydrophilic polymers (EVOH and EVA) than for hydrophobic polymers (LDPE and PP). For binary antioxidant films containing tocopherol and quercetin, the results show that tocopherol released more rapidly but for a shorter period of time than quercetin in LDPE and EVOH films, and the difference is more pronounced for LDPE films than EVOH films. The results also show the presence of tocopherol can accelerate the release of quercetin. Although none of the films produced is acceptable for long-term lipid oxidation inhibition, the study provides encouraging results suggesting that acceptable films may be produced in the future using polymer blend films.  相似文献   

2.
Both specific and overall migration tests have been applied to new experimental food packaging-active plastic films with antioxidant properties, including in its composition a natural rosemary extract. Determination of volatile and semivolatile compounds migrating from plastic to the four established simulants showed that both specific and overall migration was very low. The results obtained gave values 20 times lower than the established limits in the worst case. So, from the point of view of health risk, the new active packaging can be considered as safe. Analytical procedure used provided the necessary information about the migration behavior, with good analytical characteristics and detection limits in the sub mug kg(-1) range. Besides, no significant difference was found between laboratory and factory-made samples, which is an important issue for industrial production, the next step in the development of the new antioxidant active film.  相似文献   

3.
Microwave heating of commercial microwavable polypropylene packaging in contact with fatty food simulants caused significant antioxidant degradation and increased specific migration as shown by electrospray ionization-mass spectrometry (ESI-MS) and gas chromatography-mass spectrometry (GC-MS). Degradation of the antioxidants Irgafos 168 and Irganox 1010 was not detected during conventional heating of polypropylene packaging at the same temperature. The migration into aqueous food simulants was primarily restricted by the water solubility of the migrants. Using isooctane as fatty food simulant caused significant swelling and greatly enhanced overall migration values compared to the other fatty food simulant, 99.9% ethanol, or the aqueous food simulants 10% ethanol, 3% acetic acid, or water. ESI-MS spectra clearly reflected the overall migration values, and the number and amount of compounds detected decreased as the hydrophilicity of the food simulant increased. ESI-MS was shown to be an excellent tool for the analysis of semivolatile migrants and a good complement to GC-MS analysis of volatile migrants.  相似文献   

4.
Ethylene vinyl alcohol copolymer (EVOH) films containing green tea extract were successfully produced by extrusion. The films were brown and translucent, and the addition of the extract increased the water and oxygen barrier at low relative humidity but increased the water sensitivity, the glass transition temperature, and the crystallinity of the films and improved their thermal resistance. An analysis by HPLC revealed that the antioxidant components of the extract suffered partial degradation during extrusion, reducing the content of catechin gallates and increasing the concentration of free gallic acid. Exposure of the films to various food simulants showed that the liquid simulants increased their capacity to reduce DPPH(?) and ABTS(?+) radicals. The release of green tea extract components into the simulant monitored by HPLC showed that all compounds present in the green tea extract were partially released, although the extent and kinetics of release were dependent on the type of food. In aqueous food simulants, gallic acid was the main antioxidant component released with partition coefficient values ca. 200. In 95% ethanol (fatty food simulant) the K value for gallic acid decreased to 8 and there was a substantial contribution of catechins (K in the 1000 range) to a greatly increased antioxidant efficiency. Kinetically, gallic acid was released more quickly than catechins, owing to its faster diffusivity in the polymer matrix as a consequence of its smaller molecular size, although the most relevant effect is the plasticization of the matrix by alcohol, increasing the diffusion coefficient >10-fold. Therefore, the materials here developed with the combination of antioxidant substances that constitute the green tea extract could be used in the design of antioxidant active packaging for all type of foods, from aqueous to fatty products, the compounds responsible for the protection being those with the higher compatibility with the packaged product.  相似文献   

5.
The use of silver as an antimicrobial in the food area has raised wide interest in recent years. In the present work, 0.001-10 wt % silver ions was satisfactorily incorporated into an ethylene-vinyl alcohol (EVOH) copolymer matrix by a solvent casting technique. The antibacterial efficacy of the composite was evaluated under laboratory conditions and in contact with some foods. The ionic compound did not affect the crystallinity or the water-induced plasticization of the materials and was homogeneously distributed across the surface and thickness of the films. When immersed in water, sorption-induced release of 50-100% of the silver ions took place in <30 min. In the bacterial minimal growth medium M9, the minimal inhibitory concentration (MIC) of the film was in the range of 0.01-0.1 ppm. High protein content food samples displayed low susceptibility to the films (<1 log reduction in any case), whereas low protein content food samples exhibited no detectable bacterial counts for films with 1 and 10 wt % silver and about 2 log reduction for films with 0.1 wt % silver. These results represent a step forward in the understanding of silver antimicrobial efficacy and its possible application in the food-packaging industry, most likely as food coatings.  相似文献   

6.
Active food packaging systems based on the incorporation of agents into polymeric package walls are being designed to purposely release or retain compounds to maintain or even increase food quality. The objective of this work was to develop polyvinyl alcohol (PVOH)/β-cyclodextrin (βCD) composite films that can be applied to reduce undesirable component content such as cholesterol in foods through active retention of the compounds in the package walls during storage. Cyclodextrins were added to PVOH in a proportion of 1:1 and cross-linked with glyoxal under acidic media to reduce its water-soluble character. Three different cross-linking procedures were used: cross-linking of the polymer/polysaccharide mixture in solution and film casting, PVOH. βCD*; cross-linking of the polymer, addition of βCD, and casting of the mixture, PVOH*.CD; and casting of a PVOH film, addition of a βCD/glyoxal solution onto the film, and cross-linking during drying, PVOH.CD*. Characterization studies showed that the PVOH*.CD and PVOH.CD* films provided the best physical characteristics with the lowest release values and the highest barrier properties. As a potential application, materials were tested as potential cholesterol-scavenging films. There was a significant reduction in the cholesterol concentration in milk samples when they were exposed to the materials developed.  相似文献   

7.
Antioxidants commonly used in polyolefins were studied in commercial food packages made of low- and high-density polyethylene (LDPE and HDPE), polypropylene (PP), polyvinylchloride (PVC), and polyethylene terephtalate (PET) and in a LDPE film extruded at the laboratory. The phenolic antioxidants BHA, BHT, AO 2246, AO 425, Ethanox 330, Irganox 1010, and Irganox 1076 were studied together with the phosphite Irgafos 168 and their two degradation products, phosphate and DBP. Antioxidants were extracted from polyolefins using microwave energy and analyzed using high-performance liquid chromatography (HPLC) to determine the antioxidant content in the diverse commercial films. Irganox 1010 and Irganox 1076 were found in the majority of the samples generally together with the phosphite Irgafos 168 and its oxidized product (phosphate). Specific migration levels of each antioxidant were determined by HPLC after pretreatment with solid-phase extraction (SPE) in aqueous food simulants and after their dilution with tetrahydrofuran (THF) in fatty food simulant. These levels were much lower than limits allowed by legislation.  相似文献   

8.
The antimicrobial activity in the vapor-phase of laboratory-made flexible films of polypropylene (PP) and polyethylene/ethylene vinyl alcohol copolymer (PE/EVOH) incorporating essential oil of cinnamon ( Cinnamomum zeylanicum), oregano ( Origanum vulgare), clove ( Syzygium aromaticum), or cinnamon fortified with cinnamaldehyde was evaluated against a wide range of microorganisms: the Gram-negative bacteria Escherichia coli, Yersinia enterocolitica, Pseudomonas aeruginosa, and Salmonella choleraesuis; the Gram-positive bacteria Listeria monocytogenes, Staphylococcus aureus, Bacillus cereus, and Enterococcus faecalis; the molds Penicillium islandicum, Penicillium roqueforti, Penicillium nalgiovense, Eurotium repens, and A spergillus flavus and the yeasts Candida albicans, Debaryomyces hansenii, and Zigosaccharomyces rouxii. Films with a nominal concentration of 4% (w/w) of fortified cinnamon or oregano essential oil completely inhibited the growth of the fungi; higher concentrations were required to inhibit the Gram-positive bacteria (8 and 10%, respectively), and higher concentrations still were necessary to inhibit the Gram-negative bacteria. PP films were more effective than PE/EVOH films. The atmospheres generated by the antimicrobial films inside Petri dishes were quantitatively analyzed using headspace-single drop microextraction (HS-SDME) in combination with gas chromatography-mass spectrometry (GC-MS). The analyses showed that the oregano-fortified PP films released higher levels of carvacrol and thymol, and the cinnamon-fortified PP films released higher levels of cinnamaldehyde, during the first 3-6 h of incubation, than the corresponding PE/EVOH films. Shelf-life tests were also performed, demonstrating that the antifungal activities of the films persisted for more than two months after their manufacture. In addition, migration tests (overall and specific) were performed, using both aqueous and fatty simulants, to ensure that the films meet EU regulations regarding food contact materials. Following contact with the tested films, the substances that had migrated into the aqueous simulants were recovered by direct immersion-single drop extraction (DI-SDME) and then analyzed by GC-MS. The fatty stimulant (isooctane) was directly injected into the chromatographic system.  相似文献   

9.
Set-off is the unintentional transfer of substances used in printing from the external printed surface of food packaging to the inner, food-contact surface. Ambient ionization-accurate mass spectrometry (AMI-AMS) detected and identified compounds from print set-off not visible to the human eye. AMI mass spectra from inner and outer surfaces of printed and nonprinted food packaging were compared to detect and identify nonvisible set-off components. A protocol to identify unknowns was developed using a custom open-source database of printing inks and food-packaging compounds. The protocol matched print-related food-contact surface ions with the molecular formulas of common ions, isotopes, and fragments of compounds from the database. AMI-AMS was able to detect print set-off and identify seven different compounds. Set-off on the packaging samples was confirmed using gas chromatographic-mass spectrometric (GC-MS) analysis of single-sided solvent extracts. N-Ethyl-2(and 4)-methylbenzenesulfonamide, 2,4-diphenyl-4-methyl-1(and 2)-pentene, and 2,4,7,9-tetramethyl-5-decyne-4,7-diol were present on the food-contact layer at concentrations from 0.21 to 2.7 ± 1.6 μg dm?2, corresponding to nearly milligram per kilogram concentrations in the packaged food. Other minor set-off compounds were detected only by AMI-AMS, a fast, simple, and thorough technique to detect and identify set-off in food packaging.  相似文献   

10.
Effects of heat processing and storage time (up to 70 days) on migration of bisphenol A (BPA) and bisphenol A-diglycidyl ether (BADGE) from can coatings into an aqueous food simulant were determined. Distilled water was canned in two types of Mexican cans: for tuna and for jalape?o peppers. Results showed that there is an effect of heat treatment on migration of both compounds. Storage time did not show any effect in BPA migration from tuna cans. There was an effect of storage time on BPA migration from jalape?o pepper cans. Results for BADGE migration were affected by its susceptibility to hydrolyze in aqueous simulants. BADGE concentration decreased, or was not detected, during storage in both types of cans. Migration levels for BPA and BADGE were within 0.6-83.4 and <0.25-4.3 microg/kg, respectively. Both were below European and Mercosur legislation limits. Other migrating compounds were detected, although no identification was performed.  相似文献   

11.
Lipid oxidation is a major deteriorative factor in meats. Sources of natural antioxidants that are as effective as commercially available antioxidants are desired. The objective of this research was to investigate honey as an inhibitor of lipid oxidation in ground poultry. The antioxidant content of different varieties of honey was investigated spectrophotometrically and honey's effectiveness in reducing oxidation of ground poultry determined by monitoring thiobarbituric acid reactive substances (TBARS). Buckwheat honey had the highest antioxidant content and acacia honey the lowest. Honeys of different floral sources differed in their protection against lipid oxidation. Buckwheat honey (5%, w/w) reduced TBARS approximately 70%, whereas acacia honey reduced TBARS approximately 34% at 3 days of storage at 4 degrees C. In comparison to butylated hydroxytoluene and tocopherol (0.02% of total fat), honey (at 5% of the weight of the meat) was much more effective at preventing oxidation. Honey has great potential as an antioxidant source and may result in greater acceptability of meat products and prevent negative health implications of oxidized meats.  相似文献   

12.
The objective of this work was to study the transfer of four aroma compounds (ethyl butyrate, ethyl hexanoate, cis-3-hexenol, and benzaldehyde) from a solid and complex-flavored food matrix (sponge cake) toward and through packaging films placed in indirect contact during storage in accelerated aging conditions (38 degrees C and 86% relative humidity gradient). The efficiency of treated papers relative to that of standard paper and plastic as barrier was tested. Before storage, aroma compound volatility in the sponge cake was measured, and similar values were found between aroma compounds, due to the fat content of the sponge cake. Whatever the aroma compound, permeability values during storage were similar for the same packaging film. The plastic film was the highest barrier, whereas calendering and coating treatments applied to treated papers decreased effectively their permeability. An opposite trend was observed for aroma compound sorption into packaging films during storage.  相似文献   

13.
Active membranes and food packaging containing antioxidants like catechin and epicatechin, combined with the use of materials made of biopolymers obtained from renewable sources, could create a novel alternative to reduce oxidation in food, pharmaceutical, and cosmetic products. Poly(94% L-lactic acid) films containing 1.28% catechin and 1.50% epicatechin were extruded in a pilot plant-scale extrusion machine. The diffusion kinetics of catechin and epicatechin into 95% ethanol at 20, 30, 40, and 50 °C and 50% ethanol at 40 °C displayed Fickian release behavior and diffusion coefficients between 0.5 and 50 × 10(-11) cm(2)/s. According to the Arrhenius equation, the energy of activation for the diffusion of catechin and epicatechin in the films was 110.43 and 98.92 kJ/mol, respectively. The antioxidant activity of the films was measured in methanol extracts containing 46.42 μg/mL of catechin and 57.52 μg/mL of epicatechin as 32.90 and 36.68% of scavenging the 2,2-diphenyl-1-picrylhydrazyl radical, respectively.  相似文献   

14.
Consumers' increasing interest in the relationship between diet and health is a sign for food producers to pay more attention to potential health-protecting compounds in new product development and food processing. From a production chain perspective the choice of the raw material that is used is important for the health-protecting potential of the end product. Four apple cultivars (Jonagold, Golden Delicious, Cox's Orange, and Elstar), which can be used as fresh apples or in processed apple products, were compared with regard to flavonol, catechins, phloridzin, and chlorogenic acid concentrations and antioxidant activity. Jonagold apples possessed the highest flavonoid concentration and the highest antioxidant activity. To study seasonal differences, apples from three different harvest years were analyzed, but in three cultivars no effect on flavonoid concentration and antioxidant activity was observed. Long-term storage, both at refrigerator temperature and under controlled atmosphere conditions, was found not to influence flavonoid concentration or antioxidant activity.  相似文献   

15.
Membranes of muscle foods are more susceptible to oxidation than triacylglycerols. Hence, directing a lipid-soluble antioxidant into the membranes may reduce the oxidative deterioration of muscle tissue. The objective of this research was to use a model system of cod muscle and triacylglycerol to study the distribution of exogenous delta-tocopherol between the membranes and triacylglycerol fractions of muscle. When ethanol was the carrier solvent, more tocopherol was incorporated into the membranes than when oil was the carrier. Addition of tocopherol to the muscle before the triacylglycerol was added allowed more antioxidant to be incorporated into the membranes than for the case when the oil was added before the antioxidant. When the triacylglycerol was solid, the amount of tocopherol incorporated into the membranes was higher than if the triacylglycerol was liquid and the amount of tocopherol incorporated into the membranes was less dependent on the order of tocopherol and triacylglycerol addition. There was a competition between the membrane lipids and triacylglycerol for uptake of the delta-tocopherol. In some circumstances, some of the tocopherol did not enter either the membrane lipid or triacylglycerol phase.  相似文献   

16.
A new antioxidant active packaging material for food has been designed and developed, consisting of a polypropylene film in which some natural antioxidants have been immobilized. The antioxidant properties of the new material have been tested by using both pure myoglobin and fresh beef steaks. Two different cell configurations (glass vial and Petri dish) and four different myoglobin concentrations-according to the common content of this compound in fresh meat and meat derivatives (1080, 1995, 3332, and 4414 microg g(-1), respectively)-have been evaluated in oxidation studies. Furthermore, three different concentrations of natural antioxidants in the film (designated as PR1, PR2, and PR3) were evaluated. Once myoglobin samples and the active films were introduced in the cell, they were exposed to cool white fluorescent light to accelerate oxidation for a period of time ranging from 5 to 30 days. Remaining myoglobin concentration was measured by molecular absorption UV-vis spectrophotometry at 409 nm. Organoleptic properties and color, texture, and physical characteristics of fresh meat packaged with the new active film have also been measured to evaluate the shelf life of the packaged meat. Results showed that, compared to normal polypropylene, the active film containing natural antioxidants efficiently enhanced the stability of both myoglobin and fresh meat against oxidation processes, thus being a promising way to extend the shelf life of fresh meat.  相似文献   

17.
A novel, simple, and cheap method to synthesize antioxidant methacrylic-ferulic acid copolymer (PMAA-FA) by free radical polymerization was developed by employing a hydrogen peroxide-ascorbic acid pair to produce hydroxyl radicals acting as radical initiators. FT-IR spectra were performed to verify the insertion of ferulic acid into the polymeric chain, and the antioxidant activity of PMAA-FA was compared to that of a control polymer synthesized in the absence of antioxidant molecule. Good antioxidant activity was demonstrated by obtained materials, showing the efficiency of the polymerization method. This material could be useful in the pharmaceutical field and in the food industry (food packaging).  相似文献   

18.
Transition metal-promoted oxidation impacts the quality, shelf life, and nutrition of many packaged foods. Metal-chelating active packaging therefore offers a means to protect foods against oxidation. Herein, we report the development and characterization of nonmigratory metal-chelating active packaging. To prepare the films, carboxylic acids were grafted onto the surfaces of polypropylene films by photoinitiated graft polymerization of acrylic acid. Attenuated total reflectance/Fourier transform infrared spectroscopy, contact angle, scanning electron microscopy, and iron-chelating assay were used to characterize film properties. Graft polymerization yielded a carboxylic acid density of 68.67 ± 9.99 nmol per cm(2) film, with ferrous iron-chelating activity of 71.07 ± 12.95 nmol per cm(2). The functionalized films extended the lag phase of lipid oxidation in a soybean oil-in-water emulsion system from 2 to 9 days. The application of such nonmigratory active packaging films represents a promising approach to reduce additive use while maintaining food quality.  相似文献   

19.
The effects of molecular weight and concentration of plasticizer on physicochemical properties and stability of shellac films were investigated. Type of plasticizer was previously reported to have some effects on the stability of shellac films, and polyethylene glycol (PEG) was the plasticizer of choice for plasticizing shellac films. In this study, different molecular weights of PEG (200, 400 and 4000) were chosen at a concentration of 10% w/w of shellac films. Shellac in alcohol was prepared in a free film. The stability of shellac film was then performed at 75% RH, 40 °C for 3 months. The comparison was made between the film with and without plasticizer. Shellac films were then determined for acid value, insoluble solid, mechanical properties and water vapor permeability coefficient. It was reported that different molecular weights of PEG had some influence on physicochemical properties of the shellac films. Among different molecular weights of PEG, PEG 400 showed a suitable molecular weight that could protect the shellac chain at the carboxylic and hydroxyl groups. Therefore, the molecular weight of plasticizer played a crucial role for the protective ability at active sites. Further study was performed to investigate the effect of concentrations of PEG 400 on the stability. The results demonstrated that PEG 400 at a concentration of 10% (w/w) could prevent the polymerization process for only 4 months and a significant change of all parameters was then reported. However, a higher concentration, 20% (w/w) of PEG 400, could prolong the stability of shellac for 6 months of study. Therefore, the drawback of shellac as a natural polymer in pharmaceutical and food industries could be tackled by the appropriate size and concentration of plasticizer.  相似文献   

20.
Yam starch films, formulated with yam starch (4.00 g/100 g of solution) and glycerol (1.30 and 2.00 g/100 g of solution) in filmogenic solution, were employed as packaging to extend storage life of strawberries stored at 4 degrees C and 85% RH. The effects of yam starch films on fruits were compared to the effect of PVC (poly(vinyl chloride)) packaging. Starch and PVC films significantly reduced decay of the fruits compared to control. Compared to starch films, PVC presented the better behavior on weight and firmness retention of fruits, especially in the last 7 days of storage. Considering microbiological counts, the shelf life of control fruits was 14 days, and of all packaged samples, stored at same conditions, was 21 days. Two different formulations of yam starch film were tested and had different mechanical properties as a function of glycerol content (1.30 and 2.00 g/100 g of solution) but showed no difference when employed as strawberries packaging.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号