首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献，搜索用时 15 毫秒
1.
The optimization of solid fat content (SFC) and crystal properties of trans-free structured lipids (SL) synthesized by incorporating stearic acid into canola oil was investigated. The SLs were blended with varying amounts of palm midfraction (PMF). The SFC and crystal polymorphism were improved. The addition of sucrose stearate (S-170), sorbitan tristearate (STS), and distilled monoglycerides (DMG) to one of the blends, SL40:PMF (70:30, w/w), did not improve crystal polymorphism but had significant effects on crystal morphology. The emulsifiers significantly delayed crystal growth, resulting in smaller crystal sizes as compared to the control. They were unable to inhibit the formation of granular crystals (30-140 microm), which are undesirable in margarine, after 4 weeks of storage at 0 degrees C. Blends treated with S-170 and STS showed many small evenly distributed crystals interspersed with large crystal aggregates (after 4 weeks of storage), whereas the blend treated with DMG and the control showed irregularly shaped globular crystals, also interspersed with large crystal aggregates. However, these crystal aggregates were not observed upon visual and physical examination and may therefore not impart the sensory properties of the finished products negatively.  相似文献   

2.
The effect of cooling rate on the crystallization behavior of mixes of high-melting milk fat fraction (HMF) and sunflower oil (SFO) was studied by following nucleation with laser-polarized turbidimetry. The initial crystals were photographed, and their thermal and polymorphic behaviors, as well as chemical composition, were investigated by calorimetry, X-ray diffraction, and capillary gas chromatography. Activation energies of nucleation were calculated using the Fisher-Turnbull equation. Despite small differences in Mettler dropping points for different ratios of SFO to HMF, induction times were significantly different between samples and were shorter at a slow cooling rate for the same supercooling. Rapidly cooled samples required more time at crystallization temperature to crystallize than slowly cooled samples because molecular organization prior to nuclei formation took place under different conditions. Regardless of cooling rate or composition, all crystals were in the beta' polymorph. However, morphology, thermal behavior, and chemical composition showed differences with cooling rate. Activation free energies of nucleation were of the same order of magnitude as those published for hydrogenated SFO.  相似文献   

3.
Although it is generally assumed that the reactivity of sucrose, a nonreducing sugar, in the Maillard reaction is due to its hydrolysis into free glucose and fructose, however, no direct evidence has been provided for this pathway, especially in dry and high temperature systems. Using specifically (13)C-labeled sucrose at C-1 of the fructose moiety, HMF formation was studied at different temperatures. Under dry pyrolytic conditions and at temperatures above 250 degrees C, 90% of HMF originated from fructose moiety and only 10% originated from glucose. Alternatively, when sucrose was refluxed in acidic methanol at 65 degrees C, 100% of HMF was generated from the glucose moiety. Moreover, the relative efficiency of the known HMF precursor 3-deoxyglucosone to generate HMF was compared to that of glucose, fructose and sucrose. Glucose exhibited a much lower conversion rate than 3-deoxyglucosone, however, both fructose and sucrose showed much higher conversion rates than 3-deoxyglucosone thus precluding it as a major precursor of HMF in fructose and sucrose solutions. Based on the data generated, a mechanism of HMF formation from sucrose is proposed. According to this proposal sucrose degrades into glucose and a very reactive fructofuranosyl cation. In dry systems this cation can be effectively converted directly into HMF.  相似文献   

4.
Protein‐protein interactions between wheat flour and solvent‐extracted (SE) or nonsolvent extracted (NSE) texturized soy flours were compared. Doughs were prepared to contain varying ratios of texturized soy flour in combination with wheat flour. Sucrose esters (2.5%) were included in several formulations. Doughs were fractionated into soluble and insoluble fractions at pH 4.7 and pH 6.1. Fractions were dried, powdered, and analyzed using SDS‐PAGE and spectrophotometric techniques. Electrophoretic evaluation indicated interactions between wheat gluten proteins and texturized soy proteins in the absence of sucrose esters. Electrophoretic gels of the wheat‐soy flour mixtures maintained a characteristic soy protein band after acidification to the soy protein isoelectric point. Inclusion of sucrose esters increased the interaction. Texturization conferred effects similar to that of sucrose ester on both forms of lipid‐extracted soy. Sulfhydryl analyses using 7‐chloro‐4‐nitrobenzo‐2‐oxa‐4, 3‐diazole (NBD‐Cl) revealed no change in the relative amount of sulfhydryl groups present in doughs prepared from either the texturized soy flours or the doughs containing equal amounts of wheat starch. These data indicate that interactions between soy protein from texturized soy flours and wheat proteins are not covalent.  相似文献   

5.
The kinetics of sucrose crystallization in whey protein isolate (WPI) films was studied at 25 degrees C in four different relative humidity environments: 23, 33, 44, and 53%. The effects of protein matrix, crystallization inhibitors, and storage environment on the rate constants of sucrose crystallization were determined using the Avrami model of crystallization. It was found that a cross-linked, denatured whey protein (WP) matrix more effectively hindered sucrose crystallization than a protein matrix of native WP. The crystallization inhibitors tested were lactose, raffinose, modified starch (Purity 69), and polyvinylpyrrolidone (Plasdone C15). Raffinose and modified starch were determined to be the more effective inhibitors of sucrose crystallization. At lower relative humidities (23, 33, and 44%), the cross-linked protein matrix played a more important role in sucrose crystallization than the inhibitors. As relative humidity increased (53%), the crystallization inhibitors were more central to controlling sucrose crystallization in WPI films.  相似文献   

6.
The kinetics of crystallization of high-melting fraction (HMF) and a mixture of 40% HMF and 60% low-melting fraction (LMF) of milk fat were studied at 5 degrees C by time-resolved in-situ synchrotron X-ray diffraction. HMF crystallized in the alpha polymorph, had a longer lifetime than the ones previously reported in pure milk fat, and was almost completely solid. The HMF/LMF mixture crystallized initially in the alpha form and transformed into the beta' polymorph, with a solid fat content much lower than that of HMF. The polymorphic change was therefore attributed to a delayed sudden formation of beta' mixed crystals from the uncrystallized melt. These findings are important for the food industry and as fundamental knowledge to improve our understanding of the origin of the macroscopic physical properties of solid milk fat fractions used in many manufacturing processes.  相似文献   

7.
超声波平板冷冻提高胡萝卜冻干速率   总被引：1，自引：0，他引：1  
为了探究接触式超声波辅助平板冷冻法对固体果蔬冻干过程的影响,该文研究了接触式超声波辅助胡萝卜的平板冷冻过程。首先,利用低温显微镜证实了接触式超声波能够有效促进平板冷冻固体果蔬样品成核,并且冰晶的形态与成核温度呈显著相关性(相关系数0.99),即成核温度越高,冰晶尺寸越大。其次,研究了超声波作用参数(功率,作用时间)对胡萝卜冰晶尺寸以及冻干速率的影响。结果表明,在胡萝卜样品厚度为5 mm,样品冷冻温度为?1℃时施加178.7W功率的超声波10 s能显著提高(P0.05)样品的成核温度,使冻干胡萝卜的孔隙当量直径从无超声波辅助条件下对照组样品的(66.29±3.58)μm提高到了(80.81±3.03)μm,同时干燥至实际含水率为10%时,升华干燥速率提升了29.1%。该研究为接触式超声波辅助平板冷冻用于果蔬样品的冻干过程提供了有益参考。  相似文献   

8.
The high- and medium-melting fractions of milk fat (HMF and MMF, respectively) were crystallized in the presence of various solvents, including the low-melting fraction of milk fat (LMF), canola oil (CO), hexane, and ethyl acetate. Choice of solvent was shown to have a strong influence on phase behavior and crystallization kinetics. Dilution and solubilization effects were observed for all the blends. More solids were formed in the HMF and MMF blends with LMF than with CO, and complexes were formed between the milk fat fractions possibly because of molecular complementarity. Solids were slightly higher for the more polar ethyl acetate than for hexane. Crystallization proceeded more rapidly in the presence of LMF and ethyl acetate than in the presence of CO and hexane, respectively. According to the Hildebrand equation, HMF and MMF were ideally soluble in LMF and CO. X-ray diffraction spectroscopy (XRD) revealed the existence of liquid-state structure in mixtures of HMF/CO, HMF/LMF, MMF/CO, and MMF/LMF. The observed liquid-state structure was reminiscent of liquid crystals. No differences were observed in the structure of the liquid phase between LMF- and CO-containing mixtures.  相似文献   

9.
In many countries, baby cereals are the first solid food given to 3-4-month-old babies after weaning and to infants aged 6-12 months. Various simple technologies are traditionally used in the processing of cereals, including toasting, hydrolysis, and drying. In this study color and hydroxymethylfurfural (HMF) assays have been used to evaluate heat effects induced during the manufacture of these foods. The baby cereals analyzed were wheat, rice, oat, and four mixtures of flours. No HMF was detected in the raw flours. Toasting the flours increased HMF values by between 1.1 and 4.53 mg/kg and color (DeltaE) values by 2.51-9.34. The drying step increased HMF values by between 1.14 and 19.60 mg/kg. High values of HMF coincided with the addition of ingredients containing HMF. Color and HMF contents in sugar-amino acid model systems were much higher than in sugar systems at temperatures >100 degrees C and low moisture content.  相似文献   

10.
Pure supercritical CO2 at various pressures and temperatures was used to effect the fractionation of tetra-acyl sucrose esters (SE) from dried, ground Turkish tobacco without any further pretreatment of the matrix. It was determined that SE cannot be extracted using low density CO2 (150 atm, 60 degrees C, and 0.62 gm/mL or 200 atm, 100 degrees C, and 0.49 gm/mL), whereas other analytes, which strongly interfere with the conventional solvent extraction of SE, can be easily removed under the same conditions. At the higher temperature (100 degrees C), these same analytes that interfere with the conventional solvent extraction of SE are even more readily removed, while the very poor extractability of SE is not affected. It was demonstrated, however, that SE can be removed from the pre-extracted tobacco with supercritical CO2 if the density is greater than (or equal to) 0.73 gm/mL. The supercritical fluid extraction method has been compared with other previous extraction methods that employ conventional solvents. This study provides one of the clearest examples of how the variable density property of a supercritical fluid can be utilized to effect the fractionation of a complex mixture.  相似文献   

11.
压力、温度对穿心莲内酯超临界CO2萃取-结晶的影响   总被引：1，自引：3，他引：1  
以穿心莲浸膏为原料，进行了穿心莲内酯的超临界CO2萃取结晶分离纯化。考察了单因素参数压力、温度对穿心莲内酯纯度、结晶量等的影响。结果表明：超临界CO2萃取结晶穿心莲内酯的纯度在结晶板上呈梯度分布；在25 MPa以下，压力升高，结晶板上部晶体纯度升高，而结晶量先增后减；在结晶板下部穿心莲内酯的纯度和结晶量都是先升高后降低；温度在一定范围内能提高晶体纯度，且有利于缩短萃取结晶时间。  相似文献   

12.
This research evaluates the effect of sunflower oil wax (SFOw) addition on the crystallization behavior and functional properties of anhydrous milk fat (AMF). Induction times of nucleation, melting behavior, microstructure of crystals, and hardness were evaluated for samples of pure AMF and AMF with 0.1 and 0.25% SFOw. Results from this research show that the addition of waxes induced the onset of crystallization of AMF by inducing its nucleation, as evidenced by decreased induction times of nucleation and the formation of smaller crystals. Crystal growth after tempering was also promoted by waxes, and significantly harder lipid networks were obtained. Results presented in this paper suggest that SFOw can be used as an additive to alter the physiochemical properties of low trans-fatty acid lipids.  相似文献   

13.
尿素包接法预浓缩鱼油生理活性组分的研究   总被引：10，自引：0，他引：10       下载免费PDF全文
为了提高鱼油中生理活性组分ＥＰＡ和ＤＨＡ的含量，以鱼油乙酯为原料，将其与饱和的尿素－乙醇溶液进行包合作用，而使鱼油中的饱和脂肪酸成结晶析出，以达到预浓缩的目的。随着尿素与鱼油乙酯摩尔比的增加，或结晶温度的降低，容易获得ＥＰＡ和ＤＨＡ含量在７０％以上的制品。  相似文献   

14.
Enzymatic changes are often detrimental to quality of low-moisture foods. In the present study, effects of glass transition and water on sucrose inversion in a lactose-sucrose food model were investigated. Amorphous samples were produced by freeze-drying lactose-sucrose (2:1)-invertase (20 mg invertase/49.4 g of carbohydrate) dissolved in distilled water. Sorption isotherms were determined gravimetrically at 24 degrees C. Sucrose hydrolysis was determined by monitoring glucose content using a test kit and the amounts of fructose, glucose, and sucrose using HPLC. The glass transition temperatures, T(g), at various water contents were measured using differential scanning calorimetry (DSC). The BET and the GAB sorption models were fitted to experimental data up to a(w) 0.444 and 0.538, respectively. Water sorption and DSC results suggested time-dependent crystallization of sugars at a(w) 0.444 and above. Significant sucrose hydrolysis occurred only above T(g), concomitantly with crystallization. Sucrose hydrolysis and crystallization were not likely in glassy materials.  相似文献   

15.
High intensity ultrasound (HIU) was used to change the crystallization behavior, generate small crystals, and improve the texture of a low saturated shortening (interesterified soybean oil). Samples were crystallized at different temperatures (26, 28, 30, and 32 °C) without and with the application of HIU. Different acoustic power levels (110, 72, 61, 54, and 44 W) were used. Results show that higher acoustic powers had a greater effect on crystal size reduction, induced crystallization, and generated harder, more elastic and viscous materials. These effects were more significant when HIU was applied in the presence of crystals and when the sample was crystallized at 32 °C.  相似文献   

16.
Browning indicators in bread   总被引：7，自引：0，他引：7  
Bread is the most important food in the Spanish household and represents the largest proportion of products produced by commercial bakeries. The browning indicators furosine, hydroxymethylfurfural (HMF), and color were determined to evaluate heat effects induced during manufacture of these foods. The breads analyzed were common, special, sliced toasted, and snack breads. Identical sample preparation and HPLC conditions were used to determine HMF in all breads. The precision tested at high and low HMF concentration in breads was 2.60% and 1.57%, respectively. Recovery of HMF was 96.2%. The HMF values ranged from 2.2 to 68.8 mg/kg. Color index (100 - L) ranged from 17.0 to 38.2. The linear correlations (r(2)) between 100 - L/HMF were above 0.70 for common, special, and snack breads. Similar correlation was obtained between 100 - L/HMF in a dough baking at different times. The furosine content in common bread ranged between 125 and 208 mg/100 g of protein. No linear correlation was found between furosine and HMF. Moreover, HMF and furosine were also determined in crumb and crust. Levels of HMF had a wide range (0.9-1.76 mg/kg) and furosine was between 43 and 221 mg/100 g of protein.  相似文献   

17.
The anti-inflammatory properties of 3',4',3,5,6,7,8-heptamethoxyflavone (HMF), a citrus polymethoxylated flavone, were studied in the bacterial lipopolysaccharide (LPS)-challenge/tumor necrosis factor-alpha (TNFalpha) response in mice and in the carrageenan/paw edema assay in rats. In each of these trials, HMF administered by intraperitoneal (ip) injection exhibited anti-inflammatory activity, whereas HMF administered orally (po) produced no effects. The inhibition observed in the LPS-challenge/TNFalpha assay correlated with the HMF levels in the blood sera of mice dosed (ip) with either 33 or 100 mg/kg body weight. Low levels of HMF (0.035 +/- 0.024 ppm) were detected in the blood sera of mice dosed orally [100 mg of HMF (suspended in vegetable oil)/kg], whereas ip injection led to higher levels (0.517 +/- 0.051 ppm). This may account for the different levels of anti-inflammatory effects observed in mice following ip vs oral HMF administration. HMF metabolites, including a number of mono- and di-demethylated HMF metabolites and their glucuronic acid conjugates, were also detected, but results of these studies suggest that the glucuronidated metabolites of HMF are inactive in these inflammation models.  相似文献   

18.
Thermal decomposition of HMF has been so far studied indirectly through carbohydrate degradation reactions assuming HMF as the main product. Such studies, however, do not necessarily generate relevant information on HMF decomposition because many other products are generated simultaneously. Direct thermal decomposition using different concentrations of HMF in silica gel was studied using pyrolysis-GC-MS. Undiluted HMF generated four peaks corresponding to 5-methylfurfural, 2,5-furandicarboxaldehdye, HMF, and a major unknown peak at retention time of 20.73 min. The diluted HMF in silica gel (15-fold) generated only the first three peaks. The generation of the unknown peak was dependent on the concentration of HMF, indicating the possibility of a dimeric structure; furthermore, when HMF was generated from [U-13C6]glucose in the reaction mixture, the highest mass in the spectrum of the unknown peak showed the incorporation of 11 carbon atoms from the glucose. Thermal decomposition studies of HMF have also indicated that in the absence of amino acids it can mainly dimerize and the initially formed dimer can degrade to generate 5-methylfurfural and 2,5-furandicarboxaldehyde. On the other hand, thermal degradation of HMF in the presence of glycine generated Schiff base adducts of HMF, 5-methylfurfural, and 2,5-furandicarboxaldehdye in addition to 2-acetyl-5-methylfuran and a newly discovered adduct, 5-[(dimethylamino)methyl]-2-furanmethanol.  相似文献   

19.
Phosphorylated sucrose stearate (SE-P) was prepared by dry-heating sucrose stearate (SE) with metaphosphoric acid. The main product was deduced to be a monophosphosucrose monostearate by chemical analysis and mass spectrometry. SE-P exhibited remarkably higher solubility and emulsifying properties than SE, especially in the acidic region and in the presence of NaCl, and SE-P bound Ca2+ at a 1:1 molar ratio (SE-P/Ca2+). SE-P markedly reduced the viscosity of potato starch paste and inhibited retrogradation, whereas SE did not reduce it so much. It is thus expected that phosphorylation would be an appropriate method for improving the functional properties of SE and that SE-P could be used as a novel emulsifier and modifier with Ca2+-binding ability for starchy foods.  相似文献   

20.
Melamine-tainted food can induce renal stones in both humans and animals. We have previously reported a novel Drosophila model for the study of renal stone disease. In addition to hyperoxaluria-causing agents, we also tested herein the effect of melamine on crystal formation in Drosophila . The results indicate that administration of melamine alone caused crystal formation in a dose-dependent manner. The crystals also appeared after ingestion of melamine for 3 weeks in the Malpighian tubules of Drosophila when viewed with polarized light. Administration of potassium citrate (K citrate) was found to significantly ameliorate the melamine-induced reduction of lifespan. However, administration of K citrate failed to reduce the quantity of crystals. Because calcium oxalate is not the major crystal induced by melamine, the predominant components of melamine-induced crystals and the potential crystal inhibitors warrant further investigation.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号