共查询到20条相似文献，搜索用时 156 毫秒
1.
2.
杏仁油微胶囊制备工艺的优化 总被引：6，自引：2，他引：4
杏仁油中不饱和脂肪酸含量较高,为防止杏仁油的氧化,扩大杏仁油的用途,以麦芽糊精和牛乳分离蛋白为壁材,大豆卵磷脂为乳化剂,采用喷雾干燥法对超临界CO<,2>萃取的杏仁油进行了微胶囊化研究,采用响应面分析法研究了微胶囊的最佳配方,正交法确定了喷雾干燥的最佳工艺参数.结果表明:杏仁油微胶囊包埋最佳配方为杏仁油质量分数25%、牛乳分离蛋白质量分数25%、大豆卵磷脂质量分数2%和麦芽糊精质量分数48%,在20 MPa压力下均质处理;喷雾干燥适宜的工艺参数为进风温度180℃,出风温度80℃,进料温度50℃.在上述优化条件下可制得高质量高包埋率的杏仁油微胶囊产品,包埋率达94.7%. 相似文献
3.
柞蚕粉微胶囊化制备工艺的研究 总被引：1，自引：0，他引：1
为了更好得开发利用柞蚕资源，该文通过对微胶囊壁材的初选试验和包埋工艺的研究，确定了以spo-mo350变性淀粉、阿拉伯胶做为壁材，以柞蚕粉做为芯材，利用喷雾干燥的方法制备柞蚕粉微胶囊。通过正交试验确定微胶囊包埋最佳工艺参数为：spo-mo350变性淀粉/阿拉伯胶的质量比为4∶1，进风温度180℃，出风温度115℃，芯材/壁材的质量比为1∶1，壁材占乳化液比例30%，包埋率达86.4%。该微胶囊包埋工艺能够较好的解决柞蚕粉存在的腥味重、易氧化等问题，使其具有更广阔的应用前景。 相似文献
4.
银杏叶提取物微胶囊化研究 总被引：12，自引：4，他引：12
为使银杏叶提取物能在食品领域得到充分有价值的应用，探索采用微胶囊技术来解决银杏类黄酮难溶于水及强烈苦味的问题。本研究选用阿拉伯胶和β-环状糊精作为银杏黄酮微胶囊壁材，通过喷雾干燥进行微胶囊化。结果表明：选用阿拉伯胶和β-环状糊精(1∶1)作为银杏黄酮的微胶囊壁材，能达到较好的微胶囊化效果，且芯材与壁材的最佳配比为0.1 g/g。最佳喷雾干燥工艺条件为：进料固形物浓度为25％，进风温度为180℃，进料速度为35 mL/min。产品微胶囊化效率达90％以上。 相似文献
5.
研究目的是以大豆分离蛋白为壁材,对射流空化制备鱼油微胶囊的工艺进行优化。采用喷雾干燥法,研究壁材添加量、乳化剂添加量、芯材添加量及射流空化处理时间对乳液稳定性和鱼油微胶囊包埋率的影响,通过响应面试验分析各因素,得到最优微胶囊制备工艺,并对制备的微胶囊产品同市售产品的结构、理化特性及稳定性进行对比分析。结果表明:在壁材添加量3.21%、乳化剂添加量0.21%、芯材添加量19.70%、射流空化处理时间11.25 min工艺条件下得到的乳液稳定性较好,鱼油微胶囊的包埋率达到94.14%。微胶囊产品微观结构呈球形颗粒,结构致密,颗粒形态完整,粒径小,表面含油率较低,包埋效果好;水分含量为3.07%,溶解度为96.30%,休止角为40.39?,溶解性较好;差示扫描量热分析结果显示,微胶囊热溶解温度较高,可用于常温贮藏。包埋后的鱼油经加速贮藏试验表明微胶囊化可以提高鱼油的氧化稳定性,延长鱼油贮藏期。 相似文献
6.
7.
贮藏因素对核桃脂肪酶活性与油脂酸价的影响 总被引：16，自引：5，他引：11
试验采用不同的贮藏方法,针对影响核桃脂肪酶活性与油脂酸价因素进行了分析研究。发现核桃的水分含量、核桃贮藏温度对核桃的脂肪酶活性影响显著,核桃品种、核桃的水分含量、核桃贮藏形态及贮藏温度等条件对核桃的酸价有明显的影响,脂肪酶活性高时核桃油脂的酸价升高的速度快。核桃酸价超过7.5时酸败严重,核桃仁变色、变味。 相似文献
8.
为了防止核桃油的氧化，扩大核桃油的用途，用分子络合、乳化包埋、复凝聚等方法对超临界CO2流体萃取的核桃油进行了微胶囊化研究，以确定产品的最佳生产工艺条件。试验结果表明：采用喷雾干燥法，以大豆分离蛋白和麦芽糊精、β-环状糊精和阿拉伯胶、明胶和阿拉伯胶为壁材，均可制得高质量高包埋率的核桃油微胶囊产品；喷雾干燥法制备核桃油微胶囊适宜的工艺参数为：进料浓度20%～30%，进料温度50～60℃，进风温度160～180℃，出风温度70～80℃。 相似文献
9.
为揭示云南省石屏、大姚、景东、永平、昌宁等5个产地生产的代表性核桃品种的品质,本研究对5个产地核桃仁中的矿质元素、蛋白质、粗脂肪、脂肪酸等成分进行测定分析。结果表明,5个产地核桃仁中的磷（P）、钾（K）、钙（Ca）、镁（Mg）、铁（Fe）、锌（Zn）、铜（Cu）、锰（Mn）等8种矿质元素含量在14.26～6 780 mg/kg,其中P、 K、 Mg元素的含量较高,P和Zn含量变异系数较大;蛋白质含量为13%～19.87%,最高为永平核桃;粗脂肪含量为66.97%～72.44%,最高为景东核桃;饱和脂肪酸含量为7.47%～11.35%,不饱和脂肪酸含量为83.92%～92.53%; 17种营养成分符合正态分布,与产地无显著相关性;Ca元素与蛋白质含量存在极显著正相关,硬脂酸与油酸含量存在极显著正相关,3种不饱和脂肪酸（油酸、亚油酸、 α-亚麻酸）之间存在显著相关性;因子分析提取前3个公因子,方差累积贡献率达97.42%,对5个产地的核桃品质进行综合评价,排名依次为石屏、景东、大姚、永平、昌宁。本研究通过分析云南省5个产地主要代表性核桃品种的营养特征,为各地区核桃品种选育和深加工奠定基础。 相似文献
10.
玉米淀粉-辛烯基琥珀酸淀粉酯制备亚麻油微胶囊 总被引：5，自引：1，他引：4
为了降低生产成本,本文用价格低廉的天然蜡质玉米淀粉（NWMS）替代部分的辛烯基琥珀酸淀粉酯(OSAS)作为壁材,用高速剪切法处理乳液,经喷雾干燥后制备亚麻油微胶囊。将OSAS与NWMS按照5∶0、4∶1、3∶2和 2∶3（OSAS∶NWMS）的比例混合,试验结果表明,混合比例对于微胶囊颗粒的粒度没有显著影响;随着OSAS含量的增加,包埋率逐渐增大,当OSAS与NWMS混合比例为3∶2时,包埋率达到61.45%;随着NWMS含量的增加,微胶囊的含水率增大,表面变得更为光滑。NWMS可与OSAS混合作为亚麻油微胶囊的壁材,以达到降低成本的目的。 相似文献
11.
A method of regiospecific analysis of triacylglycerols (TAGs) in vegetable oils and animal fats is reported here using the electrospray ionization-mass spectrometry (MS(3)) of TAG-lithiated adducts. The fragment ions of the MS(3) from the loss of fatty acids at the sn-2 position as alpha,beta-unsaturated fatty acids were used for regiospecific identification and quantification. The ratio of the regiospecific TAGs, ABA and AAB, in an oil sample usually fraction collected by high-performance liquid chromatography can be determined by the abundance of the fragment ions of [ABA + Li-ACOOH-B'CH=CHCOOH]+ and [AAB + Li-ACOOH-A'CH=CHCOOH]+. The method was used to analyze regiospecific TAGs in extra virgin olive oil. The results showed that the saturated fatty acids, palmitic and stearic acids, were mostly located at the sn-1,3 positions and unsaturated fatty acids, oleic and linoleic acids, were mostly located at the sn-2 position. 相似文献
12.
Crews C Hough P Godward J Brereton P Lees M Guiet S Winkelmann W 《Journal of agricultural and food chemistry》2005,53(12):4853-4860
This paper describes the composition of walnut oils obtained from nuts collected from seven countries that are major suppliers of walnut oil. Oils were extracted from the nuts using small-scale industry pressing equipment and analyzed using standard methods for fatty acids, fatty acids in the triacylglycerol 2-position, tocopherols and tocotrienols, triacylglycerols, sterols, steradienes, and iodine value. Values for the composition of the sterols, triacylglycerols, fatty acids, iodine value, and tocopherol composition were generally in good agreement with the results of previous similar surveys. Tocotrienols were not detected in any sample. Steradienes (stigmastadiene, campestadiene, stigmastatriene, and campestatriene) were not detected in any oil. 相似文献
13.
D Firestone W Horwitz 《Journal of the Association of Official Analytical Chemists》1979,62(4):709-721
An international collaborative study of IUPAC methods II.D.19 and II.D.25 for preparation and GLC analysis of fatty acid methyl esters was begun in 1976. The IUPAC methodology, applicable to animal and vegetable oils and fats and fatty acids from all sources, contains special instructions for preparation and analysis of methyl esters of fatty acids containing 4 or more carbon atoms (analysis of milk fat). Twenty-three collaborators participated in the analysis of 5 known mixtures, 4 vegetable oils, 1 fish oil, and 2 butterfats. Several blind duplicate samples were included. The experimental data were subjected to statistical analysis to examine intra- and interlaboratory variation. Reproducibility and accuracy data for the higher fatty acid (14:0-22:1) mixtures and fish and vegetable oils were satisfactory and were in good agreement with results from an AOCS Smalley Committee check sample program involving analysis of the same samples. Typical coefficients of variation (%) at various concentrations were 15 (2% level), 8.5 (5% level), 7 (10% level), and 3 (50% level). Low recoveries and poor reproducibility were characteristics of results obtained for butyric acid in the butterfat and related known mixtures. A coefficient of variation of about 19% was found for analysis of butyric acid in butterfat, vs coefficients of variation in the range of 4-13% for similar levels of other components in butterfat and other samples. The IUPAC methodology for GLC analysis of fats and oils other than milk fats has been adopted by the AOAC as official first action to replace the current GLC method, 28.063-28.067. 相似文献
14.
为了选择合适的包装措施以减缓山核桃仁中油脂在贮藏期间的氧化酸败,延长其贮藏期,研究了用聚乙烯塑料膜（Polyethylene,PE）和聚乙烯塑料铝箔膜（Polyethylene/Al,PE/Al）的普通包装与PE、PE/Al的真空包装,4种不同包装措施对山核桃贮藏过程中油脂氧化的影响。通过不同包装对山核桃油脂的酸价、碘价、过氧化值、p-茴香胺值和脂肪氧合酶活性在贮藏过程中的变化情况的影响,确定适合山核桃的包装形式。试验结果表明PE/Al真空包装能有效减缓山核桃油脂的氧化进程,从而延缓山核桃的品质的下降,延长其货架期。 相似文献
15.
Li L Tsao R Yang R Kramer JK Hernandez M 《Journal of agricultural and food chemistry》2007,55(4):1164-1169
The fatty acid and tocopherol compositions of three heartnut (Juglans ailanthifolia var. cordiformis) varieties (Imshu, Campbell CW1, and Campbell CW3) were examined and compared with those of two Persian walnut (Juglans regia L.) varieties (Combe and Lake). The major fatty acids found in heartnuts and walnuts were identified by gas chromatography as linoleic (18:2n-6), alpha-linolenic (18:3n-3), oleic (18:1n-9), palmitic (16:0), and stearic acid (18:0). Polyunsaturated fatty acids were the main group of fatty acids found in both heartnut and walnut, ranging from 73.07 to 80.98%, and were significantly higher in heartnut than in Persian walnuts (P < 0.001). In addition, heartnuts had significantly higher levels of 18:2n-6 and lower levels of 18:3n-3 compared to the Persian walnuts. gamma-Tocopherol was the main tocopherol homologue present in both types of nuts, followed by delta- and alpha-tocopherol. The highest concentration of gamma-tocopherol was found in Combe Persian walnut at 267.87 mug/g, followed by Lake Persian walnut and Imshu, Campbell CW1, and CW3 heartnut at 205.45, 187.33, 161.84, and 126.46 mug/g, respectively. Tocopherols, particularly the gamma-tocopherol, were found to contribute the most to the strong total antioxidant activities of both walnut and heartnut oils using either the free radical 2,2-diphenyl-1-picrylhydrazyl assay or the photochemiluminescence method. 相似文献
16.
Blended oils comprising coconut oil (CNO) and rice bran oil (RBO) or sesame oil (SESO) with saturated fatty acid/monounsaturated fatty acid/polyunsaturated fatty acid at a ratio of 1:1:1 and polyunsaturated/saturated ratio of 0.8-1 enriched with nutraceuticals were prepared. Blended oils (B) were subjected to interesterification reaction using sn-1,3 specific Lipase from Rhizomucor miehei. Fatty acid composition and nutraceutical contents of the blended oil were not affected by interesterification reaction. Male Wistar rats were fed with AIN-76 diet containing 10% fat from CNO, RBO, SESO, CNO+RBO blend (B), CNO+SESO(B), CNO+RBO interesterified (I), or CNO+SESO(I) for 60 days. Serum total cholesterol (TC), low-density lipoprotein cholesterol, and triacylglycerols (TAGs) were reduced by 23.8, 32.4, and 13.9%, respectively, in rats fed CNO+RBO(B) and by 20.5, 34.1, and 12.9%, respectively, in rats fed CNO+SESO(B) compared to rats given CNO. Rats fed interesterified oils showed a decrease in serum TC, low-density lipoprotein cholesterol (LDL-C), and TAGs in CNO+RBO(I) by 35, 49.1, and 23.2 and by 33.3, 47, and 19.8% in CNO+SESO(I), respectively, compared to rats given CNO. Compared to rats fed CNO+RBO blended oils, rats on CNO+RBO interesterified oil showed a further decrease of 14.6, 24.7, and 10% in TC, LDL-C, and TAG. Rats fed CNO+SESO interesterified oils showed a decrease in serum TC, LDL-C, and TAG by 16.2, 19.6, and 7.8%, respectively, compared to rats given blended oils of CNO+SESO (B). Liver lipid analysis also showed significant change in the TC and TAG concentration in rats fed blended and interesterified oils of CNO+RBO and CNO+SESO compared to the rats given CNO. The present study suggests that feeding fats containing blended oils with balanced fatty acids lowers serum and liver lipids. Interesterified oils prepared using Lipase have a further lowering effect on serum and liver lipids even though the fatty acid composition of blended and interesterified oils remained same. These studies indicated that the atherogenic potentials of a saturated fatty acid containing CNO can be significantly decreased by blending with an oil rich in unsaturated lipids in appropriate amounts and interesterification of blended oil. 相似文献
17.
A K Athnasios E J Healy A F Gross G J Templeman 《Journal of the Association of Official Analytical Chemists》1986,69(1):65-67
A capillary gas chromatographic (CGC) method is described for the determination of cis,cis-methylene interrupted polyunsaturated fatty acids (cis-PUFA) in fats and oils. The sample is saponified and the liberated fatty acids are esterified to the corresponding methyl esters. The latter are analyzed by CGC using a 60 M. SP2340 capillary column. Area percent values for 9,12-cis,cis-C18:2 and 9,12,15-cis,cis,cis-C18:3 fatty acid methyl esters are summed to give the total cis-PUFA content. Gas chromatographic results agreed well with those obtained by an enzymatic lipoxygenase method at the 31-48% cis-PUFA levels with a correlation coefficient of 0.98. The method has a precision (relative standard deviation) of 0.33% at a 44.4% cis-PUFA level in margarine oil. 相似文献
18.
The oxidative stability of selected tree nut oils was examined. The oils of almond, Brazil nut, hazelnut, pecan, pine nut, pistachio, and walnut were extracted using two solvent extraction systems, namely, hexane and chloroform/methanol. The chloroform/methanol system afforded a higher oil yield for each tree nut type examined (pine nut had the highest oil content, whereas almond had the lowest). The fatty acid compositions of tree nut oils were analyzed using gas chromatography, showing that oleic acid was the predominant fatty acid in all samples except pine nut and walnut oils, which contained high amounts of linoleic acid. The tocopherol compositions were analyzed using high-performance liquid chromatography, showing that alpha- and gamma-tocopherols were the predominant tocopherol homologues present; however delta- and beta-tocopherols were also detected in some samples. The oxidative stability of nonstripped and stripped tree nut oils was examined under two conditions, namely, accelerated autoxidation and photooxidation. Progression of oxidation was monitored using tests for conjugated dienes, peroxide value, p-anisidine value, and headspace volatiles. Primary products of oxidation persisted in the earlier stages of oxidation, whereas secondary oxidation product levels increased dramatically during the later stages of oxidation. Hexanal was the major headspace aldehyde formed in all oxidized samples except walnut oil, which contained primarily propanal. Results showed that chloroform/methanol-extracted oils were more stable than hexane-extracted oils in both the accelerated autoxidation and photooxidation studies. Oils of pecan and pistachio were the most stable, whereas oils of pine nut and walnut were the least stable. 相似文献
19.
Enzymatic interesterification of butterfat with rapeseed oil in a continuous packed bed reactor 总被引：4，自引：0，他引：4
Rønne TH Yang T Mu H Jacobsen C Xu X 《Journal of agricultural and food chemistry》2005,53(14):5617-5624
Lipase-catalyzed interesterification of butterfat blended with rapeseed oil (70/30, w/w) was investigated both in batch and in continuous reactions. Six commercially available immobilized lipases were screened in batch experiments, and the lipases, Lipozyme TL IM and Lipozyme RM IM, were chosen for further studies in a continuous packed bed reactor. TL IM gave a fast reaction and had almost reached equilibrium with a residence time of 30 min, whereas RM IM required 60 min. The effect of reaction temperature was more pronounced for RM IM. TL IM showed little effect on the interesterification degree when the temperature was raised from 60 degrees C to 90 degrees C, whereas RM IM had a positive effect when the temperature was increased from 40 degrees C to 80 degrees C. Even though TL IM is an sn-1,3 specific lipase, small changes in the sn-2 position of the triacylglycerol could be seen. The tendency was toward a reduction of the saturated fatty acid C14:0 and C16:0 and an increase of the long-chain saturated and unsaturated fatty acids (C18:0 and C18:1), especially at longer residence times (90 min). In prolonged continuous operation the activity of TL IM was high for the first 5 days, whereafter it dramatically decreased over the next 10 days to an activity level of 40%. In general, the study shows no significant difference for butterfat interesterification in terms of enzyme behavior from normal vegetable oils and fats even though it contains short-chain fatty acids and cholesterol. However, the release of short-chain fatty acids from enzymatic reactions makes the sensory quality unacceptable for direct edible applications. 相似文献
20.
Pengguo Xia Hongbo Guo Zongsuo Liang Xiuming Cui Yan Liu Fenghua Liu 《Genetic Resources and Crop Evolution》2014,61(3):663-667
Sanchi (Panax notoginseng) root has been widely used as traditional herb to stanch blood, disperse gore and reduce pain in China for centuries. However, the nutritional information about its seed was unknown. Sanchi seeds obtained from Yunnan Province were analyzed for their nutritional composition, fatty acid, amino acid profile and sugar contents. Sanchi seeds were abundant in fats (46.35 %) and proteins (23.90 %). Notably, seven fatty acid compositions were determined and abundant in unsaturated fatty acid (99.56 %), containing 95.71 % oleic acid. Sanchi seed proteins were rich in glutenin, globulin and albumin (28.63, 27.83 and 26.81 %, respectively). Sanchi seed contain 17 kinds of amino acids, of which nine were essential amino acids, accounting for 41.30 %. These nutritional compositions indicate that Sanchi seed has the potentiality to be exploited as human edible oil, industrial use, new medicine or healthcare products for diabetes patients due to low sugar content. 相似文献