首页 | 本学科首页   官方微博 | 高级检索  
相似文献
 共查询到20条相似文献，搜索用时 31 毫秒
1.
微波辅助提取黄皮果肉果胶工艺参数优化   总被引：2，自引：1，他引：1  
为优化微波辅助提取黄皮果肉中果胶的工艺,采用均匀设计法,考察了微波功率、提取时间、液料比及提取液pH值4个因子对黄皮果胶得率的影响。利用SAS软件对试验数据进行模型拟合和回归分析,确定提取时间和液料比是影响果胶得率的重要因子,并最终获得微波辅助提取黄皮果胶的最优工艺参数为:微波功率600W,提取时间8min,液料比24:1mL/g,提取液pH值2.0。在此条件下果胶得率为3.59%。通过对果胶基本特性的测定分析,该工艺提取的黄皮果胶品质基本符合国家标准,可为黄皮果胶提取的工业化放大提供参考。  相似文献   

2.
交替双频逆流超声辅助提取条斑紫菜蛋白和多糖   总被引：2，自引：2，他引：2  
为了高值化利用条斑紫菜资源,该文采用交替双频逆流超声辅助提取技术生产条斑紫菜蛋白和多糖混合产品。研究了复合双频和交替双频2种超声模式对条斑紫菜蛋白和多糖提取效果的影响,采用中心组合设计响应面优化试验进行工艺优化。结果显示,交替双频超声模式显著优于复合双频超声模式。料液比、提取时间和温度均对提取效果影响显著。确定的交替双频逆流超声辅助提取的最优条件为:料液比14mg/mL、时间88min、温度41℃、pH值9.0、15和20kHz交替双频超声、超声交替工作时间3s、超声功率200W/L。在此最优条件下,条斑紫菜蛋白和多糖混合产品的生产能力最高,单位质量原料生产出的产品得率为(48.180.08)%,其中蛋白得率为(24.350.07)%,纯度为(45.610.33)%,多糖得率为(23.830.02)%,纯度为(44.640.37)%,比传统提取方法,得率提高了168%,时间缩短了64%;比单频逆流超声辅助提取方法,得率提高了50%,时间缩短了18%。从生产成本分析,交替双频逆流超声辅助提取方法具有明显技术优势和工业推广价值。  相似文献   

3.
微波辅助提取桔皮果胶的理化及凝胶特性比较   总被引：1，自引：1，他引：0  
为了增加桔皮利用率,提高桔皮中果胶得率和品质,以5种新鲜桔皮(丑橘、砂糖橘、芦柑、金橘、贡桔)为原料,采用微波辅助法提取桔皮中果胶,对果胶理化特性和凝胶特性进行研究。分析果胶理化及凝胶特性的相关性,并采用主成分分析法确定影响果胶凝胶特性的主要因素,优化微波辅助法提取工艺参数。结果表明:5种桔皮果胶都是高酯果胶,5种果胶理化及凝胶特性存在显著差异(P0.05),其中芦柑果胶得率和半乳糖醛酸质量分数最高,分别为12.36%、78.61%;且5种果胶理化及凝胶特性呈显著相关性(P0.05),主成分分析法确定甲氧基质量分数和果胶得率分别为主成分1和2中主要影响因子,甲氧基质量分数决定果胶种类,因此果胶种类和得率是桔皮果胶提取的主要因素。微波提取优化参数:以芦柑桔皮为原料,料液比为1:26 g/g,p H值1.30,微波功率440 W,微波时间62 s,果胶得率为16.00%。研究结果为桔皮果胶加工和应用提供理论指导。  相似文献   

4.
A study of the nonvolatile fraction of extracts from vine shoots obtained by superheated ethanol-water mixtures is presented. The influence of the temperature, extraction time, and percentage of ethanol on extraction was investigated by a multivariate experimental design to maximize the yield of total phenolic compounds, measured by using the Folin-Ciocalteu method. The best values found for these variables were 80% (v/v) ethanol, 240 degrees C, and 60 min. Under these conditions, the effect of pH was also investigated, and a strong improvement of yield was observed by decreasing the pH. The extracts were subject to liquid-liquid extraction with n-hexane. The remaining polar phase was dried in a rotary evaporator and then reconstituted in 10 mL of water. The insoluble residue was dissolved in 10 mL of methanol. Both fractions (aqueous and methanolic) were analyzed by HPLC, and the differences in composition according to the extraction conditions were studied. Compounds usually present in commercial wood extracts were identified (mainly benzoic and hydroxycinnamic acids and aldehydes); the most abundant were quantified, and the stability of the identified phenolic families under different extraction conditions was also investigated. Finally, the superiority of the superheated liquid extraction over conventional solid-liquid extraction was demonstrated.  相似文献   

5.
The aim of this work was to optimize a supercritical fluid extraction (SFE)/enzymatic reaction process for the determination of the fatty acid composition of castor seeds. A lipase from Candida antarctica (Novozyme 435) was used to catalyze the methanolysis reaction in supercritical carbon dioxide (SC-CO(2)). A Box-Behnken statistical design was used to evaluate effects of various values of pressure (200-400 bar), temperature (40-80 degrees C), methanol concentration (1-5 vol %), and water concentration (0.02-0.18 vol %) on the yield of methylated castor oil. Response surfaces were plotted, and these together with results from some additional experiments produced optimal extraction/reaction conditions for SC-CO(2) at 300 bar and 80 degrees C, with 7 vol % methanol and 0.02 vol % water. These conditions were used for the determination of the castor oil content expressed as fatty acid methyl esters (FAMEs) in castor seeds. The results obtained were similar to those obtained using conventional methodology based on solvent extraction followed by chemical transmethylation. It was concluded that the methodology developed could be used for the determination of castor oil content as well as composition of individual FAMEs in castor seeds.  相似文献   

6.
The viability of the purification of lactulose from a mixture with lactose [70:30 (w/w)] using pressurized liquid extraction (PLE) at 1500 psi for 30 min was studied. Different temperatures (from 40 to 130 degrees C) and proportions of ethanol:water (70:30, 80:20, 90:10, 95:5, and 100:0) as the extraction solvent were assayed. Lactose and lactulose were measured by gas chromatographic analysis as their trimethylsilyl derivatives. Data were fitted through multiple linear regressions to different quadratic models to describe both the extraction yield (in terms of mg of lactulose) and the purity of the lactulose extracted. The optimum extraction conditions provided by the model were as follows: extraction temperature, 40 degrees C; and solvent composition, 70:30 ethanol:water. PLE extraction under the optimized conditions was also applied to purify lactulose from lactose in a synthesis mixture. To our knowledge, this is the first time that PLE has been tested for extraction and purification of lactulose from its mixture with lactose; this technique showed several advantages over classical methods such as the short extraction time and the low solvent consumption.  相似文献   

7.
以杜仲叶为原料,正交试验优化了微波辅助提取绿原酸的工艺条件。应用高速逆流色谱（HSCCC）分离制备高纯度杜仲叶绿原酸,通过质谱技术与核磁共振技术进行结构鉴定。结果表明,杜仲叶最佳提取工艺条件为微波辅助50%的丙酮水溶液浸提,料液比1∶30,提取时间25min,提取功率400W,绿原酸的提取率达2.28%;高速逆流色谱法...  相似文献   

8.
Sorghum proteins have the potential to be used as a bio‐industrial renewable resource for applications such as biodegradable films and packaging. This project was designed to evaluate the effect of interactions between sorghum protein extraction and precipitation conditions on the yield, purity, and composition of sorghum protein fractions. Proteins were extracted with 70% ethanol under nonreducing conditions, with ultrasound, or under reducing conditions using either sodium metabisulfite or glutathione as the reducing agent. Several conditions were used to isolate the extracted proteins through precipitation, including lowering ethanol concentrations alone or in combination with lowering to pH 2.5, or by adding 1M NaCl to the extract. Combinations of these conditions were also tested. All precipitation conditions effectively precipitated proteins and lowering the pH and adding 1M NaCl to the extracts enhanced precipitation in some cases. However, the conditions that precipitated the maxium amount of protein or highest purity of protein varied according to how the proteins were initially extracted. Precipitated proteins were characterized by RP‐HPLC, SEC, HPCE, and SDS‐PAGE to compare the protein fractions composition. Nonreduced and sonicated samples had a much wider Mw distribution than reduced extracts. Thus, extraction and precipitation conditions influenced the isolated proteins yield, purity, and composition. Because the extraction and purification processes influenced the composition, purity, and biochemical properties, it may be possible to prepare protein fractions with unique functionalities for specific end‐uses.  相似文献   

9.
In this work, extraction of antioxidant compounds from Dunaliella salina microalga is optimized by combining pressurized liquid extraction (PLE) and experimental design (three-level factorial design) with three different solvents (hexane, ethanol, and water). Two main factors were considered, the extraction temperature (40, 100, and 160 degrees C) and the extraction time (5, 17.5, and 30 min). As response variables, the extraction yield (percent dry weight/initial weight) and the antioxidant activity of the extracts (determined using the TEAC method) were used. The parameters of the model were estimated by multiple linear regression. Results showed that the extraction temperature was the factor having the strongest influence (positive) on the two response variables. The best yields were obtained with ethanol at the higher extraction temperature and time tested. Besides, although hexane extracts provided the best antioxidant activity, ethanol extracts were also very active. The chemical characterization of ethanol extracts was carried out using HPLC-DAD, and attempts have been made to correlate their chemical composition with the antioxidant activity measured. Results pointed out that the extracts contained, besides all-trans-beta-carotene and isomers, several different minor carotenoids that seemed to make a contribution to the antioxidant activity of the extracts.  相似文献   

10.
由于提取率和产品品质等方面的原因,作为玉米秸秆主要成分之一的木聚糖还未能得到充分有效的利用。为改善玉米秸秆木聚糖的提取率和品质,对影响木聚糖提取的碱浓度和温度2个关键因素进行了研究。使用组分分析和凝胶渗透色谱等手段对木聚糖得率、纯度和结构进行了研究,同时分离得到纤维素和醇溶木质素。结果表明,Na OH浓度对木聚糖得率和结构的影响比温度显著,较优提取条件为:Na OH浓度为10%(w/v),提取温度90℃,此条件下木聚糖的溶出率和回收率分别为86.37%和76.92%,木聚糖纯度为63.90%。凝胶渗透色谱结果显示,碱浓度的增加使木聚糖的分子量降低,而随温度的升高则呈先升后降的趋势。此外,提取剩余物中纤维素的含量随碱浓度和温度强度的增加而增加。研究证明组合适当的碱浓度和提取温度可以在保证品质的前提下得到较高的木聚糖提取率。  相似文献   

11.
Green labeled pectins were extracted by an environmentally friendly way using proteases and cellulases being able to act on proteins and cellulose present in cell walls. Pectins were isolated from different plant byproducts, i.e., chicory roots, citrus peel, cauliflower florets and leaves, endive, and sugar beet pulps. Enzymatic extraction was performed at 50 degrees C for 4 h, in order to fulfill the conditions required for microbiological safety of extracted products. High methoxy (HM) pectins of high molar mass were extracted with three different enzyme mixtures. These pectins were subsequently demethylated with two pectin methyl esterases (PMEs), either the fungal PME from Aspergillus aculeatus or the orange PME. It was further demonstrated that high molar mass low methoxy (LM) pectins could also be extracted directly from cell walls by adding the fungal PME to the mixture of protease and cellulase. Moreover, health benefit pectic oligosaccharides, the so-called modified hairy regions, were obtained after enzymatic treatment of the residue recovered after pectin extraction. The enzymatic method demonstrates that it is possible to convert vegetable byproducts into high-added value compounds, such as pectins and pectic oligosaccharides, and thus considerably reduce the amount of these residues generated by food industries.  相似文献   

12.
The valorization of extracts from Brazilian vetiver (Vetiveria zizanioides (L.) Nash ex Small) roots was studied. This study took into account the extraction method, the chemical composition of the extracts, their sensorial characteristics, and the possibility of chemical transformations of the product. The performed extraction methods were hydrodistillation and extraction with supercritical carbon dioxide. Some pretreatment methods were tested on the vetiver roots and evaluated in terms of extraction yield, process time, chemical composition, and sensorial properties. Supercritical carbon dioxide extraction resulted in high yield (3.2%) in significantly less time than the other methods. The chemical compositions of the extracts obtained by the different methods were also compared to those of commercial vetiver oils from other sources, showing that Brazilian samples had a greater acid amount. An extraction in basic medium from Brazilian vetiver oil was done to remove its main acid (zizanoic acid), which was chemically transformed into an alcohol (khusimol) of desirable sensorial properties. Sensory evaluation indicated that the Brazilian volatile oil without acid could be used in perfumery and the extract obtained with supercritical carbon dioxide could have application in food.  相似文献   

13.
Medium-chain triacylglycerol (MCT)-enriched oil was extracted by supercritical fluid extraction of carbon dioxide (SFE-CO(2)) from Cinnamomum camphora seeds. The SFE-CO(2) process was optimized using the Box-Behnken design (BBD). The maximum oil yield (42.82%) was obtained under the optimal SFE-CO(2) conditions: extraction pressure, 21.16 MPa; extraction temperature, 45.67 °C; and extraction time, 2.38 h. Subsequently, the physicochemical characteristics, fatty acid composition, triacylglycerol (TAG) composition, tocopherol content, and DSC profile as well as oxidative stabilities of C. camphora seed oil (CCSO) were studied. Results showed that CCSO contained two major medium-chain fatty acids, capric acid (53.27%) and lauric acid (39.93%). The predominant TAG species in CCSO was LaCC/CLaC (ECN 32, 79.29%). Meanwhile, it can be found that CCSO had much higher oxidative stabilities than coconut oil due to the higher content of tocopherols in CCSO (α-tocopherol, 8.67 ± 0.51 mg/100 g; γ-tocopherol, 22.6 ± 1.02 mg/100 g; δ-tocopherol, 8.38 ± 0.47 mg/100 g). Conclusively, CCSO with such a high level of MCTs and high oxidative stabilities could be potentially applied in special food for specific persons such as weak patients and overweight persons because oils enriched in MCTs can be rapidly absorbed into body to provide energy without fat accumulation.  相似文献   

14.
A recently developed pilot-scale process for the extraction of starch and by-products from wrinkled peas was used to determine the attainable yield and purity of starch and by-products from different varieties of these peas. It was shown that the starch yield mainly depends on the removal of the starch from the fibers. From the pilot scale experiments, it could be concluded that, for an industrial process, the optimum values of the total starch yield of wrinkled peas and the purity of the starch in relation to the starch content of the starch fraction would be ~80 and 98%, respectively. The best possible value that can be achieved for mechanical separation of the protein from the starch is in the range of 1.5% protein content of the starch fraction. The protein content can be adjusted to values ≤0.5% by alkali extraction of the starch fraction. Similar positive results cannot be achieved for the other fractions. In addition, the water flow balance in the pilot plant demonstrated that the process water flows can only be limited to an economically feasible size when applying membrane filter technology.  相似文献   

15.
超高压提取丹参素的研究   总被引：2，自引：0，他引：2  
该文研究常温下超高压提取丹参素的最优工艺.采用超高压常温提取,正交试验对丹参素超高压提取工艺优化,高效液相色谱法测定丹参素的含量,并与传统的热回流提取法进行比较.结果显示优选的最优工艺为:提取压力300 MPa,溶剂乙醇浓度80%,溶液pH 13,浸泡时间16 h,在此条件下丹参素得率为0.465%.超高压提取不仅得率高、时间短、耗能低,而且提取产物易于分离、纯化,同时超高压提取可以维持在低温下进行,特别适宜于受热不稳定化合物的提取,该技术适合中药有效成分的快速提取.  相似文献   

16.
曹熙  杨大伟 《核农学报》2021,35(12):2787-2798
为鉴定黄花菜多酚类化合物的结构并研究漂烫与贮藏对其稳定性的影响,本研究采用响应面和正交试验设计,四极杆飞行时间液质串联系统,以及三重四极杆液质串联系统,研究了超声波辅助提取黄花菜多酚,HPD-600大孔树脂吸附多酚,乙醇解吸附多酚的最佳条件,对多酚类化合物进行分离纯化和结构鉴定,并对新鲜、漂烫与室温贮藏的黄花菜多酚类化合物含量进行分析。结果表明,超声辅助提取黄花菜多酚类化合物的最佳条件为:乙醇浓度66%,时间22 min,温度43℃,料液比1∶12 g·mL-1, 此条件下多酚得率为2.12%;HPD-600大孔树脂吸附多酚的最佳条件为温度50℃,pH值6,吸附时间3 h,此条件下多酚吸附率为28.76%;无水乙醇解吸附的最佳条件为温度60℃,pH值6,解吸时间3 h,此条件下多酚解吸率为78.94%,纯化的多酚溶液浓度为0.61%;黄花菜多酚类化合物的含量由高到低依次为芦丁、绿原酸和槲皮素,高温漂烫和贮藏极易引起多酚类化合物的损失,导致加工后黄花菜的营养品质下降。本研究结果可为黄花菜多酚类化合物的分离鉴定及漂烫和室温贮藏对其稳定性影响的研究提供参考。  相似文献   

17.
小麦麸皮阿拉伯木聚糖碱提工艺条件优化研究   总被引：2，自引：0，他引：2  
为提高小麦麸皮中阿拉伯木聚糖的得率,本研究在考察了温度、时间、碱液与H2O2浓度和振荡速度等单因素对阿拉伯木聚糖得率影响的基础上,采用二次回归正交旋转组合设计对阿拉伯木聚糖的碱提工艺条件进行了优化并建立数学模型。结果表明,在提取温度88℃、时间200min、NaOH浓度0.16mol/L、H2O2浓度1.5%的条件下,阿拉伯木聚糖的得率达到最大值21.23%,验证实验结果与模型预测值相符。  相似文献   

18.
微波提取法对樱桃、猕猴桃和枸杞多糖特性的影响   总被引：2，自引：1，他引：1  
微波提取是近年来发展迅速的天然产物提取技术之一。为考察微波提取对多糖得率、结构及生物学功能的影响,论文采用微波功率1 000 W和提取温度140℃,以不同提取时间5,10 和20 min分别对樱桃、猕猴桃和枸杞中多糖进行提取。结果表明,微波提取多糖的得率、相对分子质量和抗氧化性低于传统提取方法,随着微波提取时间延长,多糖相对分子质量逐步降低,但多糖得率与抗氧化性无显著变化;微波提取得到的多糖在单糖组成上与传统提取方法有一定的差异。该研究结果对应用微波提取水果多糖条件的选择及多糖品质控制有一定的参考价值。  相似文献   

19.
菜籽蛋白的提取和纯化   总被引：6，自引：0，他引：6  
为了对菜籽饼进行综合利用,以低温压榨制油的双低菜籽饼为原料,探讨了菜籽蛋白的提取和纯化工艺.通过料液pH值的先后调节对比、正交、提取次数和纯化试验,得到较佳工艺条件:采用先调pH值法,水溶液的pH值为12,提取时间为20 min,温度为室温,提取3次,通过pH5和7的两步沉淀,经干燥得到分离蛋白,蛋白纯度达84.8%,得率为38.9%,且有害物质残留较少.先调pH值法与后调法相比,总的提取率可提高20个百分点,达90%以上.  相似文献   

20.
Ground paprika (Capsicum annuum L.) was extracted with supercritical carbon dioxide (SC-CO(2)) and subcritical propane at different conditions of pressure and temperature to estimate the yield and variation in carotenoid, tocopherol, and capsaicinoid contents and composition. The yield of paprika extract was found to be affected by the extraction conditions with SC-CO(2) but fairly constant at different conditions with subcritical propane. The maximum yields of oleoresin were 7.9 and 8.1% of ground paprika by SC-CO(2) and subcritical propane, respectively. The quantitative distribution of carotenoids, tocopherols, and capsaicinoids between paprika extract and powder was influenced by extraction conditions. SC-CO(2) was inefficient in the extraction of diesters of xanthophylls even at 400 bar and 55 degrees C, whereas tocopherols and capsaicinoids were easy to extract at these conditions. Under mild conditions subcritical propane was superior to SC-CO(2) in the extraction of carotenoids and tocopherols but less efficient in the extraction of capsaicinoids.  相似文献   

设为首页 | 免责声明 | 关于勤云 | 加入收藏

Copyright©北京勤云科技发展有限公司  京ICP备09084417号