不同增稠剂对农药可分散油悬浮剂稳定性的影响     

陈罗云  姜震东  刘江钰  郑鹭飞  吴学民 《农药学学报》2020,22(2):233-242

为明确不同增稠剂对以矿物油为分散介质的油悬浮体系稳定性的影响,以12.5%丙炔·吡嘧(丙炔噁草酮·吡嘧磺隆)可分散油悬浮剂为对象,通过流变学和多重光散射方法,研究了有机膨润土、有机高分子和气相二氧化硅3类增稠剂单独使用及有机膨润土和其他两类增稠剂分别搭配使用对可分散油悬浮剂物理稳定性的影响。结果表明:所有样品的流动特性指数(n)均小于1,为假塑性流体,具有触变性。除有机膨润土和高分子增稠剂Atlox Rheostrux100组合使用时体系更符合Casson方程外,其余样品均更符合Herschel-Bulkley方程。单独使用时,有机膨润土对保证体系稳定的效果相对较好;Atlox Rheostrux 100和Atlox Rheostrux200两种高分子增稠剂的效果差别较大,其中Atlox Rheostrux 100效果更好,这可能是由分子结构差异造成;两种气相二氧化硅类增稠剂由于不能有效形成氢键,效果较差。将有机膨润土和有机高分子增稠剂组合使用时,体系的稳定性有所提升,其中有机膨润土869和Atlox Rheostrux 100组合使用效果更好,体系具有较高的黏度,且具有良好的触变性,物理稳定性优异;有机膨润土869和疏水气相二氧化硅R974组合使用时则效果没有明显的提升。研究表明,流变学和多重光散射两种方法均能较好地表征可分散油悬浮剂的物理稳定性;新型高分子增稠剂和有机膨润土具有协同作用,将二者合理组合添加能大幅提升可分散油悬浮剂的稳定性。  相似文献   

Structural,rheological and gelatinization properties of wheat starch granules separated from different noodle-making process     

《Journal of Cereal Science》2020

In this study, three typical wheat cultivars (ZM366, AK58, and ZM103) with high, medium, and low gluten strength, respectively, were selected as the raw material. The starch granules separated from different stages of the noodle-making process, including kneading, resting, sheeting, cutting, and drying, were used to explore the structure, dynamic rheology, and quality of the noodles. The D50 (median diameter) of the starch granules decreased during the noodle-making process, and the reduction was enhanced by an increase in the gluten strength of the flour. Between steps 4 and 5 of the noodle-making process, the solubility of ZM103 variety increased from 4.3% to 5.0% at 80 °C, while the peak viscosity decreased from 3626 to 3386 mPa s, which resulted in a decrease in the cooking loss of noodles. Similar trend was observed in the ZM366 and AK58 varieties. The gelatinization enthalpy was reduced, suggesting that the crystalline regions of the starch granules were destroyed during the kneading process. Between steps 4 and 5 of the noodle-making process, the elastic modulus of the starch granules significantly increased, while the temperature at which maximum elastic modulus was decreased, indicating an increase in the crystalline stability of starch during the drying process. Correlation analysis indicated that the changes occurred to the gelatinization property was primarily due to the change in the particle size.  相似文献   

Rheological properties of pasta dough during pasta extrusion: Effect of moisture and dough formulation     

Elena de la Peña  Frank A. Manthey  Bhavesh K. Patel  Osvaldo H. Campanella 《Journal of Cereal Science》2014

A study was conducted to investigate the effect of dough formulation and hydration level on the rheological properties of pasta dough during pasta extrusion. Semolina 100%, whole wheat 100%, and the following mixtures semolina-whole wheat (49:51), semolina-flaxseed flour (90:10), whole wheat-flaxseed flour (90:10), and semolina-whole wheat-flaxseed flour (39:51:10) were the formulations used for the experiments. Dough was hydrated at 30, 32, and 34% moisture content. Pasta was extruded with a capillary and a semi-commercial pasta extruder to determine the apparent viscosity of the dough during extrusion conditions and its relationship to the behavior of the dough during pasta processing. Results showed that non-traditional pasta dough behaved like a shear thinning fluid that can be described by the Power Law model. Increased hydration levels and/or presence of flaxseed flour on the dough formulation decreased the apparent viscosity of the dough, which correlated with extrusion pressure, mechanical energy, and specific mechanical energy that were required to extrude the dough in the pasta extruder. The strong correlations found between the apparent viscosity of the dough and the pasta extrusion parameters indicates the possibility of using a capillary rheometer to determine the appropriate hydration level of ingredient formulations before extruding with a pasta press.  相似文献   

马来松香对木粉/HDPE复合材料流变性质的影响   总被引：2，自引：1，他引：1  

欧荣贤  王清文 《林业科学》2009,45(5)

用马来松香对木粉进行流动性能改善处理,与高密度聚乙烯(HDPE)熔融复合,挤出成型制备木粉/HDPE复合材料(WF-HDPE).利用傅里叶变换红外光谱(FTIR)和X-射线光电子能谱(XPS)技术,分析经马来松香改性前后木粉表面官能团的变化和元素的变化,采用旋转流变仪研究.WF-HDPE的流变行为.FrIR与XPS分析表明,马来松香分子中的酸酐基团与木粉表面的羟基发生了酯化反应,并且马来松香是以单酯的形式接枝到木粉表面,同时产生一游离羧基.WF-HDPE流变学研究表明:复合材料的复合黏度(η*)、储能模量(G′)和损耗模量(G″)随马来松香用量的增加先减小后增大最后减小,但体系的黏度和模量总体呈下降趋势,木粉经马来松香改性后复合熔体的流变性能显著改善,这不仅有利于提高复合材料的成型加工效率,而且适当的马来松香处理也能够提高复合材料的拉伸强度和弯曲强度,后者被静态力学试验结果所证实.  相似文献   

Strain Hardening Properties and Extensibility of Flour and Gluten Doughs in Relation to Breadmaking Performance     

J.J. Kokelaar  T. van Vliet  A. Prins 《Journal of Cereal Science》1996,24(3):199-214

The mechanical properties of flour–water doughs and hydrated gluten of different wheat cultivars were determined. Measurements were performed at small deformations (dynamic measurements) as well as at large deformations (biaxial extension measurements). Results of dynamic measurements of flour doughs related poorly to breadmaking quality. For hydrated gluten doughs, all having the same water content, it was found that glutens from wheat cultivars with good baking quality had higher values for the storage modulus,G, and lower values for the loss tangent. The relevant type of deformation around an expanding gas bubble is biaxial extension. Wheats with a good baking performance exhibited greater strain hardening and greater extensibility. The differences in strain hardening observed at 20 °C were also present at 55 °C. No clear effects of NaCl or emulsifiers on the biaxial extension properties of flour dough were found. Extensograms as well as Alveograms from the flour doughs showed that, in general, good baking flours exhibited stronger resistance to extension and a greater extensibility, but differences found were not directly related to the results of the baking tests. The results indicate that the baking performance of dough is related to a combination of at least three different rheological characteristics.  相似文献   

软质小麦品质性状与酥性饼干品质参数的关系研究   总被引：31，自引：0，他引：31  

张岐军  张艳  何中虎  R J Pe 《作物学报》2005,31(9):1125-1131

选用我国17份软质小麦品种（系）在3点种植2年，研究软质小麦品质性状与酥性饼干品质的关系，探讨优质饼干品种的筛选指标。结果表明，粉质仪和拉伸仪参数与饼干品质的相关系数较小；吹泡仪弹性、吹泡仪弹性/延伸性、碱水保持力（AWRC）、碳酸钠溶剂保持力（SRC）和蔗糖SRC与饼干直径关系密切，相关系数分别为－0.79、－0.75  相似文献   

A simulated experiment on the high titanium slag rheological behavior     

BAI Chen-guang  HUANG Run  QIU Gui-bao  YU Yao-wei  PAN Cheng  MAO Lei 《保鲜与加工》2011,(3):64-68

The rheological property of high titanium slag is a main factor to influence the vanadium titanomagnetite smelting in blast furnace. It plays a great role in discharging slag, separating iron and slag and even the life of blast furnace hearth. The acrylonitrile-butadiene-styrene multipolymer(ABS) dense suspension is taken to simulate the system of high titanium slag. Apparent viscosity is measured by a NXS-11A rotating cylinder viscometer. The impact of temperature, volume fraction and particle sizes on the suspension apparent viscosity is studied. The results show that temperature and volume fraction have a strong influence on the suspension apparent viscosity, while the particle size has a weak effect. The suspension shows Bingham behavior within a wide concentration range. The dependence of the appear viscosity on temperature and amount of solid addition can be described by a binary function equation.  相似文献   

国外农业生物材料研究中的力学试验     

孙振华 《新疆农业大学学报》1988,(1)

本文综述了近30年来国外农业生物材料研究中的力学试验及其主要成果,对农业现代化、农业机械设计、机械化收获、加工、运输、提高产量、评价农产品等方面均有意义。  相似文献   

环道试验条件下稠油O/W乳状液的性质     

孟江  任连城  魏小林  张燕 《油气储运》2012,31(3):167-170,247,248

利用试验环道对胜利新滩含水65%稠油的W/O乳状液采用转相乳化法形成O/W乳状液的性质进行测试。3种不同方案的试验结果表明:在相同条件下,环道试验配制的乳状液液滴尺寸分布范围大,稳定性较差;在其他条件不变时,环道流量和乳化剂加量对乳状液的动态稳定性影响较大;流量越大,O/W乳状液的动态稳定性越好;在一定范围内,乳化剂加量越大,O/W乳状液稳定性越好。在管流条件下,形成O/W乳状液和乳化剂在管壁吸附均可降低管输摩阻,乳状液的稳定性是影响管道压降的主要因素。温度变化对O/W乳状液的表观粘度影响不大,同时,加剂0.8mg/g形成的O/W乳状液停输再启动不存在困难。  相似文献   

Effect of sodium chloride on gluten network formation,dough microstructure and rheology in relation to breadmaking     

Thu H. McCann  Li Day 《Journal of Cereal Science》2013

Sodium chloride (NaCl) is an essential ingredient to control the functional properties of wheat dough and bread quality. This study investigated the effect of NaCl at 0, 1 and 2%, (w/w, flour base) on the gluten network formation during dough development, the dough rheology, and the baking characteristics of two commercial flours containing different levels of protein (9.0 and 13.5%) and with different glutenin-to-gliadin ratios. Examination of the dough structure by confocal microscopy at different stages of mixing show that the gluten network formation was delayed and the formation of elongated fibril protein structure at the end of dough development when NaCl was used. The fibril structure of protein influenced the dough strength, as determined by strain hardening coefficient and hardening index obtained from the large deformation extension measurements. NaCl had a greater effect on enhancing the strength of dough prepared from the low protein flour compared to those from the high protein flour. The effect of NaCl on loaf volume and crumb structure of bread followed a similar trend. These results indicate that the effect of NaCl on dough strength and bread quality may be partially compensated by choosing flour with an appropriate amount and quality of gluten protein.  相似文献