| 旋风除尘器对生物炭粉的除尘特性 |
| |
| 引用本文： | 李永军,易维明,何 芳,柏雪源,李志合,蔡红珍.旋风除尘器对生物炭粉的除尘特性[J].农业工程学报,2012,28(3):60-64. |
| |
| 作者姓名： | 李永军 易维明 何 芳 柏雪源 李志合 蔡红珍 |
| |
| 作者单位： | 山东理工大学山东省清洁能源工程技术研究中心,淄博,255091 |
| |
| 基金项目： | 国家自然科学基金资助（50876056，51076087，51006065）；淄博市科技基金项目（22010GG01083） |
| |
| 摘 要： | 生物炭粉是生物质热解液化工艺的主要副产品之一,其被清除的效果对生物油质量有较大影响。该文以下降管式生物质热解液化装置作为试验平台,试验分析了旋风除尘器对炭粉的除尘效果。该工艺中,进入旋风除尘器的热解气含尘浓度范围一般为35～50g/m3,且浓度随机波动较大;旋风除尘器收集的炭粉粒径范围为0.39～30μm的颗粒占总量的91.29%,几乎没有小于0.39μm和大于40.72μm的颗粒;旋风除尘器的除尘效率不高,一般低于80%。旋风除尘器的除尘效率随热解气中炭粉浓度增加而略有提高。
|
| 关 键 词： | 除尘 效率 试验 热解 旋风除尘器 |
| 收稿时间： | 2011/7/13 0:00:00 |
| 修稿时间： | 2011/8/30 0:00:00 |
Removal effect of biochar powder from biomass pyrolysis by clone dust remover |
| |
| Li Yongjun,Yi Weiming,He Fang,Bai Xueyuan,Li Zhihe and Cai Hongzhen.Removal effect of biochar powder from biomass pyrolysis by clone dust remover[J].Transactions of the Chinese Society of Agricultural Engineering,2012,28(3):60-64. |
| |
| Authors: | Li Yongjun Yi Weiming He Fang Bai Xueyuan Li Zhihe and Cai Hongzhen |
| |
| Institution: | (Shandong Research Center of Engineering and Technology for Clean Energy,Shandong University of Technology,Zibo 255091,China) |
| |
| Abstract: | Biochar powder is one of the principle byproducts from the biomass pyrolysis process and its removal efficiency from the pyrolysis vapor affects the quality of subsequent oil product significantly.In this study,the dust removal characteristic of a cyclone was investigated experimentally on a drop-tube fast pyrolysis reactor.In this reactor,dust concentration in the pyrolysis vapor before entering the cyclone of was about 35-50 g/m3 and varied randomly.Results showed that 91% of particles of char dust collected in the cyclone were between 0.39 and 30 μm in size.And amount of particles which were smaller than 0.39 μm or bigger than 40 μm were negligible.The dust removal efficiency of the cyclone was less than 80%.With the increase of the dust concentration in pyrolysis vapor,the dust removal efficiency of the cyclone increases slightly. |
| |
| Keywords: | dust control efficiency experiments pyrolysis cyclone |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
| 点击此处可从《农业工程学报》浏览原始摘要信息 |
| 点击此处可从《农业工程学报》下载免费的PDF全文 |
|
