| 基于ATmega128单片机的开沟深度自控系统试验台的设计 |
| |
| 引用本文： | 蔡国华,李 慧,李洪文,王庆杰,何 进,倪际梁.基于ATmega128单片机的开沟深度自控系统试验台的设计[J].农业工程学报,2011,27(10):11-16. |
| |
| 作者姓名： | 蔡国华 李 慧 李洪文 王庆杰 何 进 倪际梁 |
| |
| 作者单位： | 中国农业大学工学院,北京,100083 |
| |
| 基金项目： | 公益性行业（农业）科研专项（200903009） |
| |
| 摘 要： | 为免耕播种机开沟深度自控系统开发做铺垫,该文设计了一种开沟深度自动控制系统室内试验台,该试验台由检测单元、控制器、驱动板、液压系统、调节机构、开沟器等组成,实现了开沟深度跟踪控制.试验结果表明:当开沟深度相对期望开沟深度过深或过浅50 mm时,其稳态响应时间分别为0.48与0.6s,误差均小于10mm;当地表模拟板起伏...
|
| 关 键 词： | 单片机 设计 农业机械 开沟深度 电液比例控制 试验台 |
| 收稿时间： | 2011/1/26 0:00:00 |
| 修稿时间： | 2011/8/29 0:00:00 |
Design of test-bed for automatic depth of furrow opening control system based on ATmega128 single chip microcomputer |
| |
| Cai Guohu,Li Hui,Li Hongwen,Wang Qingjie,He Jin and Ni Jiliang.Design of test-bed for automatic depth of furrow opening control system based on ATmega128 single chip microcomputer[J].Transactions of the Chinese Society of Agricultural Engineering,2011,27(10):11-16. |
| |
| Authors: | Cai Guohu Li Hui Li Hongwen Wang Qingjie He Jin and Ni Jiliang |
| |
| Abstract: | To develop an automatic depth of furrow opening control system for no-till seeders, an automatic depth of furrow opening control system for indoor test-bed was designed. It was made up of a measuring unit, a controller, a driving board, hydraulic system, adjusting mechanism, an opener, and so on. And it achieved tracking control of the depth of furrow opening. The results indicated that when the depth of furrow opening was 50 mm deeper than the desired value, the steady-state response time was about 0.48 s ,and when that is shallower than the desired value ,the steady-state response time was about 0.6 s, The maximum error of them both were less than 10 mm. The results also showed that when the undulation slope of surface imitating board was smaller(motor speed was about 10 r/min), the dynamic response error was limited to -30-30mm ,when that was bigger (motor speed was about 25 r/min), the dynamic response error was limited to -60-40 mm. The imitating static and dynamic response experiment could be carried out based on this test-bed for automatic depth of furrow opening control system, while control strategy should be studied further to decrease time of improve the performance of the system. |
| |
| Keywords: | microcontrollers design agriculture machinery depth of furrow opening electro-hydraulic proportional control test-bed |
| 本文献已被 CNKI 万方数据 等数据库收录！ |
| 点击此处可从《农业工程学报》浏览原始摘要信息 |
| 点击此处可从《农业工程学报》下载免费的PDF全文 |
|
